At least one recall carries a do-not-drive or park-outside warning. Confirm by VIN that the repair was completed before driving or buying this car. The fix is free at a dealer.
Recalls
Safety issues the manufacturer must repair for free. A recall means confirm the fix was done, not walk away.
Electrical system recall
A short circuit in the starter relay may increase the risk of a fire.
- Remedy
- Owners are advised to park their vehicles outside and away from structures until the remedy is complete. Dealers will replace the engine starter, free of charge. Owner notification letters were mailed February 6, 2026. Owners may contact BMW customer service at 1-800-525-7417. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov November 14, 2025.
- Status
- Park outside and away from buildings until repaired. Dealer fixes it free.
- What to do
- Enter the VIN on NHTSA's recall lookup to confirm this car was repaired.
Seat belts recall
An audible chime that does not properly alert the driver to fasten their seat belt increases the risk of injury in a crash.
- Remedy
- Dealers will update the receiver audio module software, free of charge. Owner notification letters were mailed October 12, 2023. Owners may contact BMW customer service at 1-800-525-7417.
- Status
- Remedy available. Confirm by VIN that this repair was completed.
- What to do
- Enter the VIN on NHTSA's recall lookup to confirm this car was repaired.
Safety recall
An improperly welded seat frame may not properly restrain the occupant during a crash, increasing the risk of injury.
- Remedy
- Dealers will replace the seat frame and back rest, free of charge. Owner notification letters were mailed May 22, 2023. Owners may contact BMW customer service at 1-800-525-7417.
- Status
- Remedy available. Confirm by VIN that this repair was completed.
- What to do
- Enter the VIN on NHTSA's recall lookup to confirm this car was repaired.
Safety recall
If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.
- Remedy
- BMW will notify owners, and dealers will inspect the rearview camera software and update it if necessary, free of charge. The recall began April 16, 2021. Owners may contact BMW customer service at 1-800-525-7417.
- Status
- Remedy available. Confirm by VIN that this repair was completed.
- What to do
- Enter the VIN on NHTSA's recall lookup to confirm this car was repaired.
Steering recall
A damaged or fractured tie rod may affect vehicle handling and control, increasing the risk of a crash.
- Remedy
- BMW and Toyota will notify owners, and dealers will replace the steering gear tie rods, free of charge. The recall began August 14, 2020. Owners may contact BMW customer service at 1-800-525-7417 or Toyota customer service at 1-888-270-9371.
- Status
- Remedy available. Confirm by VIN that this repair was completed.
- What to do
- Enter the VIN on NHTSA's recall lookup to confirm this car was repaired.
Seat belts recall
If the air bag and/or seat belt pretensioners deploy improperly in the event of a crash, there is an increased risk of injury to the driver and front passenger.
- Remedy
- BMW will notify owners, and dealers will inspect and replace the front seat belt buckles, as necessary, free of charge. The recall began May 18, 2020. Owners may contact BMW customer service at 1-800-525-7417.
- Status
- Remedy available. Confirm by VIN that this repair was completed.
- What to do
- Enter the VIN on NHTSA's recall lookup to confirm this car was repaired.
Seat belts recall
In the event of a crash, if the seat belt pretensioners fail to lock, there is an increased risk of injury.
- Remedy
- BMW will notify owners, and dealers will replace the rear seat belts, free of charge. The recall is expected to begin February 10, 2020. Owners may contact BMW customer at 1-800-525-7417.
- Status
- Remedy available. Confirm by VIN that this repair was completed.
- What to do
- Enter the VIN on NHTSA's recall lookup to confirm this car was repaired.
Exterior lighting recall
Headlight failure can reduce the driver's visibility, increasing the risk of a crash.
- Remedy
- BMW will notify owners, and dealers will replace the headlight control units, free of charge. The recall is expected to begin January 17, 2020. Owners may contact BMW customer service at 1-800-525-7417 or Toyota customer service at 1-888-270-9371.
- Status
- Remedy available. Confirm by VIN that this repair was completed.
- What to do
- Enter the VIN on NHTSA's recall lookup to confirm this car was repaired.
Structure recall
If a person were inside the trunk compartment, they may not be able to get out, increasing their risk of injury.
- Remedy
- BMW will notify owners, and dealers will inspect the interior trunk release cable and properly install the cable, as necessary, free of charge. The recall began December 13, 2019. Owners may contact BMW customer service at 1-800-525-7417.
- Status
- Remedy available. Confirm by VIN that this repair was completed.
- What to do
- Enter the VIN on NHTSA's recall lookup to confirm this car was repaired.
Safety recall
If the counterbalance shaft loosens, severe engine damage could occur, increasing the risk of a crash.
- Remedy
- BMW will notify owners, and dealers will replace the engine, free of charge. The recall began December 13, 2019. Owners may contact BMW customer service at 1-800-525-7417.
- Status
- Remedy available. Confirm by VIN that this repair was completed.
- What to do
- Enter the VIN on NHTSA's recall lookup to confirm this car was repaired.
Safety recall
The lack of an image in the back-up camera display increases the risk of a crash.
- Remedy
- BMW will notify owners, and dealers will update the back-up camera software, free of charge. The recall began November 8, 2019. Owners may contact BMW customer service at 1-800-525-7417 or Rolls-Royce at 1-877-877-3735. Toyota owners may contact Toyota customer service at 1-888-270-9371.
- Status
- Remedy available. Confirm by VIN that this repair was completed.
- What to do
- Enter the VIN on NHTSA's recall lookup to confirm this car was repaired.
Owner complaints by system
Unverified reports owners filed with NHTSA, grouped by the part of the car. Useful for spotting patterns. Open a group to read recent examples.
Engine & powertrain
18
Most reports here involve fluid leaks. Of these, 2 mention a crash.
Read full complaint
The left hydraulic engine motor mount (P/N 22117581621) completely collapsed and failed at 6 years and only 24,811 miles. The right mount was also replaced at the same time (P/N 22117581622). The failure allows unsafe, excessive engine movement and shifting under rotational torque loads. This shifting creates an immediate safety hazard, risking the sudden compromise of surrounding mechanical systems, cooling lines, and electrical harnesses while the vehicle is in motion. BMW North America acknowledged the premature nature of the failure by approving a goodwill repair for the labor costs but forced me to pay out-of-pocket for the defective parts. The engine mount issue was detected when the vehicle went in for normal services and the known recall for the engine starter which had the potential to cause bodily harm as well as property harm due to fire risk, even when the engine was off.
Source: NHTSA complaint ODI #11758531 · view all complaints for this vehicle at nhtsa.gov
Electrical & infotainment
20
Most reports here involve fire.
Read full complaint
The contact owns a 2020 BMW 330i. The contact stated that upon starting the vehicle, the starter made an abnormal, grinding metal-like sound. The vehicle was taken to the dealer, who diagnosed that the starter had failed. The starter was replaced under NHTSA Campaign Number: 26V056000 (Electrical System); however, the vehicle failed to start one morning post-repair. The message "Engine Cannot Start" was displayed. The vehicle was towed back to the dealer, where it was diagnosed that the starter failure had caused damage to the battery. The dealer informed the contact that the battery needed to be replaced prior to the starter replacement. Additionally, the contact was informed that the transmission harness, signal wire, and ending harness had overheated and needed to be replaced. The manufacturer was made aware of the failures, and a case was opened. The failure mileage was approximately 110,897.
Source: NHTSA complaint ODI #11743497 · view all complaints for this vehicle at nhtsa.gov
Steering, suspension & tires
3
Most reports here involve loss of steering.
Read full complaint
On November 15th 2025, while driving at highway speed in my lane, the vehicle’s lane assist system applied a sudden and unexpected steering input. I did not command a lane change or steering correction. The steering input caused the vehicle to become unstable, rotate, and spin across the roadway, resulting in a collision with the highway barrier. Prior to the incident, the vehicle had repeatedly failed to install a BMW-issued lane assist software update despite multiple attempts following BMW’s published instructions. BMW dealership personnel were aware of the update failure. The lane assist system remained active and provided no warnings or limitations. Weather conditions changed rapidly due to a brief, unexpected ice storm lasting approximately ten minutes. The vehicle did not provide a warning, restriction, or automatic disengagement of the lane assist system under these conditions. The loss of control occurred immediately following an unexpected steering intervention by lane assist. The loss of control occurred immediately following the steering intervention.
Source: NHTSA complaint ODI #11713830 · view all complaints for this vehicle at nhtsa.gov
Airbags & seat belts
5
Most reports here involve airbags not deploying. Of these, 2 mention a crash, 3 mention an injury.
Read full complaint
The contact owned a 2020 BMW 330i. The contact stated that while accelerating from a complete stop and making a left turn, another vehicle, trying to beat the light and driving 60 MPH, crashed into the driver's side of the vehicle. The contact was trapped because the front driver's side door failed to open. The air bags failed to deploy. The police officers delayed their arrival, and a police report was not filed. The contact was in shock. The contact drove to the residence and was able to exit the vehicle through the front passenger's side door. The contact sustained C8-T1 nerve injuries, spinal injuries, and underwent surgery, developed myelopathy, severe PTSD, severe whiplash, and the contact sustained right eye bruises after hitting her eye against the steering wheel. The T1 neck screw that was previously installed in the contact's neck had backed out due to the impact and was replaced. The contact was informed that she nearly sustained paralysis due to the crash impact. The vehicle was taken to an autobody repair shop, and the vehicle was totaled by the insurance company. The dealer was not contacted. The manufacturer was notified of the failure and sent an engineer who performed the vehicle inspection. The manufacturer later sent a letter to the contact, providing an engineering explanation for the air bag's failure to deploy. The failure mileage was approximately 6,500.
Source: NHTSA complaint ODI #11715850 · view all complaints for this vehicle at nhtsa.gov
Structure & body
3
Most reports here involve other issues.
Read full complaint
Within days of purchasing the vehicle, multiple warning lights and safety-related alerts appeared, including repeated check engine warnings, an alert stating “Driver Assistance Support Reduced,” and a wrench indicator referencing an auto lighting and wiping system malfunction. While driving, the vehicle felt unstable and would sway side to side, making it difficult to maintain confident control. The vehicle was brought in for service shortly after purchase due to these concerns and was removed from my possession because of the seriousness of the issues. During the service process, I was informed that the vehicle had previously been involved in an accident and that a critical structural safety component (the front crash bar) was damaged. This damage had not been disclosed prior to purchase. The crash bar is a key part of the vehicle’s body structure designed to absorb impact and protect occupants in a collision. Driving a vehicle with damage to this component posed a potential safety risk. The combination of structural damage, reduced driver assistance alerts, visibility system warnings, and unstable handling raised concerns about crash protection, vehicle control, and overall safety. The issues were identified by the selling dealer during inspection after the vehicle was returned for service and are available for further inspection if requested.
Source: NHTSA complaint ODI #11706202 · view all complaints for this vehicle at nhtsa.gov
Other systems
3
Most reports here involve premature wear. Of these, 1 mention an injury.
Source: NHTSA complaint ODI #11711701 · view all complaints for this vehicle at nhtsa.gov
How does it compare with other years? The 2020 has 52 complaints on file, more than the 2019 (41) and more than the 2021 (29). That is the most of the 5 model years of the BMW 330i we cover. Older model years have had longer to collect complaints.