I am writing to formally document serious and recurring safety concerns with my Certified Pre-Owned 2024 BMW X5e, which I purchased from BMW of Sterling on XXX. On XXX I was merging onto [XXX] during morning rush hour when my vehicle suddenly lost power and shut down in the middle of traffic. The vehicle first displayed a yellow drivetrain warning indicating that I could continue driving at reduced power to the nearest service center. Almost immediately afterward, a red drivetrain warning appeared instructing me to seek service immediately. At that point, the vehicle would not restart and continued displaying the error message. Having a vehicle suddenly become disabled in the middle of a major interstate during rush-hour traffic was both frightening and extremely dangerous. I contacted BMW Assist but was transferred among several representatives without receiving meaningful assistance. VDOT ultimately responded, and the vehicle was towed at my expense to BMW of Sterling. Ultimately, I was informed that BMW of Sterling could not identify the cause of the failure or replicate the problem. I was told that BMW in Germany had been consulted and that the vehicle's electronics had been reset. When I picked up the vehicle, I specifically asked whether it had been tested in electric, hybrid, and sport modes and was told that it had. However, my BMW app indicated that the vehicle had not been charged since before I brought it in for service, which raised concerns for me about the extent of the testing that was performed. On XXX, I drove the vehicle to [XXX], for work. When I returned to the vehicle that afternoon and attempted to start it, I received the same drivetrain warning messages. After approximately 15 minutes, the vehicle eventually started normally, and I was able to drive home without further incident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Source: NHTSA complaint ODI #11763444 · view all complaints for this vehicle at nhtsa.gov

I purchased my 2024 BMW X5 new at BMW Alexandria, Virginia it’s have approximately 34,000 miles . I have taken X5 into dealer warranty repairs regarding malfunction emergency call system since May 2026. Total 3 visits to dealer to resolve this issues has been unsuccessful in resolving the issues . At the moment ,‘‘quote’’from dealership below: the shop foreman has opened the TASARA CASE on the vehicle....and has sent the information to the head engineer of BMW OF NORTH AMERICA. We are waiting on a response at to what to do with the issue that we have....it may need a new HUH module . On two additional separate visits 2 TCU or TSB modules and 1 wiring harness were replaced. On 06/30/26 dashboard warning emergency call malfunction REAPPEAR AGAIN. There are numerous complaints regarding this issues online forum . BMW should take responsibility in resolving this matter maybe it’s in need of a major recall . Furthermore , defects in the emergency call system may result in loss of life / injury what the system was designed features. When I made my purchase on this X5 BMW I was believing its was reliable and trustworthy had me thinking otherwise. 7/14/26 Gotten call today from service advisor they may not be able to resolve issue and mentioned option but didn’t go into details . Afterwards received 2nd text from my service advisor case would be expedited to head engineer of BMW . Wondering what next ??

Source: NHTSA complaint ODI #11750450 · view all complaints for this vehicle at nhtsa.gov

I am requesting NHTSA assistance regarding a serious and recurring braking safety concern involving our BMW X5. We initially reported braking problems to BMW and brought the vehicle to the dealership for evaluation. We were advised that the vehicle was operating normally. Subsequently, a brake related recall was issued, and the vehicle underwent recall related service. Despite this, braking concerns continued. We again reported the problem and were advised after evaluation that the vehicle was operating properly. There were subsequent incidents involving abnormal braking behavior. During 1 incident, my wife was slowly parking the vehicle when it did not stop as expected despite repeatedly applying the brake pedal. The vehicle continued moving and collided with a wall before eventually stopping. We have also experienced abnormal brake vibration and other concerning braking behavior. Because of these repeated safety concerns, the vehicle is currently the subject of pending lemon law litigation involving BMW North America. Most recently, we returned the vehicle to the BMW dealership because of the braking and safety concerns. The vehicle remained there for approximately 4 months. We have not received a clear explanation of what diagnostic testing, inspection, repair, or corrective work was performed during this extended period. We were then informed that the vehicle was ready for pickup. When we went to retrieve it, it was covered with substantial dust and had very low tire pressure. We were unable to take it home. Our primary concern is safety. We do not know whether the reported braking malfunction was identified or corrected, what was done during approximately 4 months at the dealership, or the technical basis for releasing the vehicle for operation. We regularly transport our young children in this vehicle and are extremely concerned about driving it without knowing whether the braking problem has been properly identified and addressed. We respectfully request

Source: NHTSA complaint ODI #11758732 · view all complaints for this vehicle at nhtsa.gov

Car's information system was giving error stating: "Urgent interior functionality check up. The driver restraint system of your vehicle is malfunctioning. There is an increased risk of injury in case of a collision." Took it to the BMW dealer, they shared this info: Cause: Read out faults found fault 930949 knee air bag drivers short to negative need to replace harnesses as per SIB 65-27-24. Correction: Replace harness for knee air bags. The estimate for this is $2,013.72 which breaks down to parts at $288.96 and 7 hours worth of labor costing $1,724.76. This car is two years old. I would assume this is a manufacturing defect happening at only two years of age.

Source: NHTSA complaint ODI #11712478 · view all complaints for this vehicle at nhtsa.gov

Driving at 70 mph down a clear stretch of highway, no cars in front, panoramic sunroof spontaneously exploded. Not under an overpass, no flying debris. Temperature was 54 degrees F. on a sunny day. The vehicles behind me pulled back as my sunroof showered them. Wife and daughter in vehicle, fortunately, the panoramic shade was closed, so no debris impacted anyone. As it’s visible on the pictures, the explosion was outwards.

Source: NHTSA complaint ODI #11739165 · view all complaints for this vehicle at nhtsa.gov

The air conditioning fan has five fan beats starting with extra low, low, medium, high and extra high. The extra low is too low, but when you turn the fan speed up to one, it becomes as loud as the highest setting often sounding way too loud where it is hard to hear anything. Causes a problem then when adjusting buttons to get it to your temperature, especially while driving on an expressway. Vehicle was taken in and looked at by the dealership, but returned with the same issue and issues have also been reported online by various owners of the vehicle.

Source: NHTSA complaint ODI #11745118 · view all complaints for this vehicle at nhtsa.gov