This vehicle emits raw fuel fumes under pressure while driving and after parked for up to 45 minutes. Sometimes can her the fuel boiling in the fuel tank. If parked n a garage and any spark is near the vehicle will blow up. If parked outside the fumes are overpowering and if someone drops a cigarette nearby there will be an explosion.. I have contacted the local BRP Can A, dealer and they refuse to look at or repair due to liability concerns. I contacted BRP AND RECEIVED A CASE NUMBER 2 months ago and they have and continue to address the dangerous problem. The vehicle is a time bomb and I can not use the vehicle at all due to safety concerns.

Source: NHTSA complaint ODI #11537557 · view all complaints for this vehicle at nhtsa.gov

THE TURN SIGNAL SWITCH, WHEN CANCELED, WILL JUMP TO THE OPPOSITE DIRECTION, FOR EXAMPLE, AFTER CHANGING LANES ON THE FREEWAY, I TURN ON TO ENTER THE LEFT LANE AND AFTER MOVING INTO THE LANE I PUSH THE CANCEL ON THE SWITCH BUT IT WILL CHANGE TO A RIGHT HAND TURN SIGNAL. THE TURN SIGN INDICATOR LIGHTS ARE IMPOSSIBLE TO SEE IN CERTAIN LIGHT CONDITIONS SO THE SIGNAL REMAINS ON. THE SOFTWARE IS SUPPOSED TO TURN THE SIGNALS OFF AFTER SO LONG BUT THIS FUNCTION TAKES FAR TO LONG AND MAY NOT WORK AT ALL AT TIMES. AFTER EXITING THE FREEWAY I HAD SIGNALED RIGHT TO EXIT THE RAMP. AT THE STOP SIGN AT THE END OF THE RAMP I WAS PROCEEDING TO GO STRAIGHT AND FAILED TO NOTICE THAT MY LEFT HAND SIGNAL WAS NOT ON. A CAR THAT WAS TURNING INTO MY LANE THOUGHT I WAS TURNING LEFT AND PROCEEDED TO MAKE HIS RIGHT HAND TURN, I TOOK EVASIVE ACTION AND BOTH THE OTHER CAR AND I WOUND UP OFF THE ROAD. HE WAS FURIOUS AND THREATENED ME, I DENIED THAT I HAD PLANNED TO TURN WHEN I SEEN THAT MY LEFT SIGNAL WAS STILL FLASHING AS THE BIKE IDLED ON. THIS HAS BECOME A SERIOUS PROBLEM FOR ME ON MANY OCCASIONS, SUCH THAT I TRY TO CHECK MY SIGNAL AFTER EVERY USE. THE DEALER AND MANUFACTURER ARE AWARE BUT HAVE NO SOLUTION OTHER THAN TO REPLACE WITH A NEW BUT EXACTLY THE SAME SWITCH. SO MANY OTHER SPYDER OWNERS HAVE HAD THIS SWITCH REPLACED THAT IT IS COMMON KNOWLEDGE THAT THIS WILL NOT FIX THE PROBLEM. *TR

Source: NHTSA complaint ODI #10492369 · view all complaints for this vehicle at nhtsa.gov

THE WINDSHIELD IS MOUNTED ON THREE STRUTS -- THE MIDDLE ONE CONTROLS THE UP AND DOWN POSITION OF THE SHIELD AND HOLDS IT IN POSITION; THE OUTER TWO MOVE FREELY UP AND DOWN WITH NO RESTRAINT. THE CENTER STRUT BROKE CAUSING THE WINDSHIELD TO SUDDENLY FLY UP AND BACK AND THEN SETTLE IN AGAINST THE FRONT OF THE MOTORCYCLE. IN THAT POSITION, FULL WIND FORCE IS DIRECTED AGAINST THE RIDER AND PASSENGER. FURTHER, THE OUTER TWO STRUTS ARE FREE TO MOVE UP AND DOWN SO ANY PASSING TURBULENCE SUCH AS ANOTHER CAR OR TRUCK CAUSES THE WINDSHIELD TO LITERALLY FLAP IN THE BREEZE. I AM FILING THIS COMPLAINT ONLY NOW BECAUSE ON 09/20/2014 I OBSERVED THAT THE NEW REPLACEMENT STRUT WAS CRACKED OVER HALF-WAY THROUGH. THERE ARE APPROX 8475 MILES ON THE NEW REPLACEMENT STRUT (TOTAL MILEAGE ON VEHICLE 37575). I CONSIDER THIS A SAFETY ISSUE AS THE UNEXPECTED TOTAL FAILURE OF THE STRUT AND THE WINDSHIELD SUDDENLY FLYING UP AND BACK COULD EASILY CAUSE THE RIDER TO SWERVE OR REACT IN SOME WAY AND CAUSE AN ACCIDENT. IT IS APPARENT FROM MY HAVING TWO FAILURES THAT BRP (THE MANUFACTURER OF CAN AM MOTORCYCLES) HAS NOT IMPROVED THE DESIGN, MATERIAL OR MANUFACTURE OF THESE SIMPLE STRUTS. THIS CONCLUSION IS SUPPORTED BY THEIR NOT HAVING CHANGED THE PART NUMBER FOR THE 2011 AND 2012 MODEL YEARS NOR THE PART NUMBER OF THE REPLACEMENT PART FOR THOSE YEARS. THIS CONCLUSION IS FURTHER SUPPORTED BY THE EXPERIENCE OF OTHER RIDERS OF THIS MOTORCYCLE WHO HAVE REPORTED FAILURES ON THE INTERNET FORUMS, IN SOME CASES HAVING FAILURE OF THE REPLACEMENT STRUT AS WELL AS THE ORIGINAL, JUST AS I HAVE. FURTHER SUPPORT IS EVIDENCED BY MY DEALERSHIP TECHNICIAN WHO IS REPLACING THE CURRENT PARTIALLY CRACKED STRUT INFORMING ME THAT HE HAS REPLACED BROKEN STRUTS ON THIS MODEL MOTORCYCLE FOR OTHER CUSTOMERS. I DO NOT KNOW THE EXACT NUMBER AND I DO NOT KNOW IF HE HAS HAD OTHER REPLACEMENT STRUTS FAIL. *TR

Source: NHTSA complaint ODI #10638483 · view all complaints for this vehicle at nhtsa.gov

TL* THE CONTACT OWNS A 2011 CAN AM SPYDER ROADSTER. THE CONTACT STATED THAT DUE TO THE EXHAUST BECOMING EXTREMELY HOT, THE CONTACT BURNED HER LEG. THE CONTACT STATED THAT THE EXHAUST WAS DIRECTLY AIMED AT THE LEG OF THE DRIVER. THE DEALER ADVISED THE CONTACT TO BRING THE VEHICLE BACK AND EXCHANGE IT FOR ANOTHER VEHICLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGE WAS 238. THE VIN WAS UNAVAILABLE.

Source: NHTSA complaint ODI #10405506 · view all complaints for this vehicle at nhtsa.gov