The upper radiator hose on some huge percentage of these trucks fail (mine has failed at just over 5k miles). You can check the Colorado Chevy forum, youtube, etc., et al, and find plenty of instances where this has failed. As this is the cooling system, it can cause the engine to overheat and potentially ruin the engine. The flaw seems to be an engineering issue with the rubber seal they use (instead of a high quality o-ring) to seal the upper hose to the radiator. Additionally, since this can cause engine failure it should be addressed immediately. Instead, my local Chevy dealer, since its not a recall item, said they could schedule a time next week for me to LEAVE the truck and then they would get to it in 10-14 days. This is extremely unfair to the consumer who depends on these vehicles. This should absolutely be a recall item. You can find 1000's of examples online and if you can pull GM repair data, I'm sure you'll find 1000's more.

Source: NHTSA complaint ODI #11725209 · view all complaints for this vehicle at nhtsa.gov

Erratic operation. Indicator in side mirrors flickering with no object present. Dealer installed a new left side blind spot monitor which was tested and found to be defective, Have been waiting more than a week to have another one delivered.

Source: NHTSA complaint ODI #11754936 · view all complaints for this vehicle at nhtsa.gov

The contact's husband owns a 2025 Chevrolet Colorado. The contact stated that after exiting a car wash tunnel and parking the vehicle on the side of the car wash building, the vehicle continued to roll forward at a high speed without warning. The contact used both feet and excessive force on the brake pedal to stop the vehicle; however, the vehicle continued to roll forward. The vehicle ran over the parking pillar and crashed into a brick column attached to the building. The vehicle continued to roll forward after the crash and eventually stopped once it rolled over the car wash road indentation. The contact reversed out of the car wash indentation and called her husband for assistance. After her husband arrived at the scene; the vehicle was driven to the residence without any further issues. The vehicle remained at the residence and was not yet diagnosed or repaired. The manufacturer was notified of the failure, and the contact was provided a case number. The failure mileage was approximately 111,817.

Source: NHTSA complaint ODI #11745625 · view all complaints for this vehicle at nhtsa.gov