Vehicle has roughly 64,000 miles on it. As we were actively driving, vehicle suddenly lost power and completely shut off. This was a sudden stall. Vehicle would not crank back up but starter would engage. Upon scanning the trouble codes, multiple codes came up in regard to the fuel pump issue that is currently under investigation. (P008A, P00C6, P0304) This issue poses a serious risk as while actively driving, could cause an accident and should be an active recall for this year make and model.

Source: NHTSA complaint ODI #11762677 · view all complaints for this vehicle at nhtsa.gov

The ipma module which controls the lane keep assist has stopped working permanently. The dealership has quoted the cost to replace the ipma at over $1,000. The warning light stating that the front camera module and lane keep assist are unavailable appears each time the vehicle is started up.

Source: NHTSA complaint ODI #11754394 · view all complaints for this vehicle at nhtsa.gov

ABS break lights and Service Advanced Trac lights flashing and beeping. Eventually Break fluid low lights came on and car would not break when driving . Leaked break fluid on driveway. Car was unable to be driven, no breaks .all happened very quickly and without any reason .i had it towed to a break mechanic and he said it was the ABS modular break line that was broken and there was no more break fluid and it had leaked out . He suggested I send it to the dealership. It sounds like the exact same issue as the recall # 25S47 on campaign 25V314 but my vin number does not fall under they but shows it is the same Kentucky plant and year so I do believe it is the same issue

Source: NHTSA complaint ODI #11750075 · view all complaints for this vehicle at nhtsa.gov

1. There was front suspension failure where the lower ball joint has separated, causing the steering knuckle and wheel assembly to detach and collapse while driving- yes it is available to inspect if done tomorrow 2. Driver could not control car, passengers and other cars on road in immediate danger. Car was swerving with loss of control 3 Independent service center looked-this should have not have happened. 4 No happened yesterday was going to bring to dealer after Ind looked at it 5. No warning

Source: NHTSA complaint ODI #11758376 · view all complaints for this vehicle at nhtsa.gov

The contact owns a 2022 Ford Expedition. The contact stated that while driving approximately 75 MPH, the sunroof windscreen flew off and landed on the highway. The vehicle was taken to a dealer, where it was determined that the sunroof windscreen needed to be replaced. The vehicle was repaired; however, the failure reoccurred approximately five months later. The contact stated that while driving approximately 75 MPH, the sunroof windscreen flew off onto the highway again. The vehicle was taken to the same dealer, where it was determined that the sunroof windscreen needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 32,065.

Source: NHTSA complaint ODI #11733250 · view all complaints for this vehicle at nhtsa.gov

I am reporting a potential safety defect involving the HVAC air vent assemblies in my 2022 Ford Expedition. I have now had TWO separate vent directional-control/deflector handles break during normal use. The plastic attachment points are extremely thin and fragile and appear inadequate for a component specifically designed to be routinely adjusted. This does not appear to be an isolated incident. Broken HVAC vent controls/deflectors have been reported MULTIPLE times by Ford owners across various online Ford forums and owner discussions. The number of similar consumer reports raises concern that this may be a recurring design or material defect rather than normal wear or accidental damage. When the control breaks, the vent can no longer be properly aimed. This creates a potential visibility issue because HVAC airflow is necessary to clear condensation and fog from the windshield and front side windows. In hot humid climate, windows can fog rapidly. Losing the ability to properly direct airflow can delay clearing the glass and reduce driver visibility. The defect also prevents proper A/C airflow from being directed toward the driver. Florida vehicles can reach extremely high interior temperatures when parked. Reduced ability to direct cold air toward the driver can contribute to excessive heat exposure, discomfort, fatigue, dehydration, and potentially heat-related illness, which may impair safe vehicle operation. Having two separate vent controls fail under normal use, combined with numerous similar reports from other Ford owners, suggests a possible systemic durability defect. I am requesting that NHTSA review complaints involving 2022 Ford Expeditions and other Ford vehicles using the same vent assemblies to determine whether an investigation or corrective action is warranted.

Source: NHTSA complaint ODI #11757260 · view all complaints for this vehicle at nhtsa.gov