Deputy was going to an incident and after arrival at the scene the patrol car began to smoke, and flames were seen within the wheel well. Deputy was not in the vehicle when the fire was discovered, and Fire responded and extinguished the flames - but not before major damage to the engine compartment.

Source: NHTSA complaint ODI #11671520 · view all complaints for this vehicle at nhtsa.gov

The center display went blank and a/c controls under it would not work. Stopped vehicle and pushed ignition button to off and waited 1 minute and pushed ignition back to on on and display was still blank. Got to destination and pushed ignition to off. The next day when I got into vehicle and pushed ignition button to on the display worked.

Source: NHTSA complaint ODI #11746112 · view all complaints for this vehicle at nhtsa.gov

Purchased new from dealer. At 3500 miles, noticed rattling and clunking noise under front end, more noticeable at speeds less than 35. Took to dealer who diagnosed as worn struts, saying shocks and struts need to be replaced, but they need to order parts. When asked if safe to drive, was told "yes", but "avoid potholes". Now waiting to hear from dealer when parts come in. They stated it would take 4 to 5 hours to repair/replace.

Source: NHTSA complaint ODI #11635531 · view all complaints for this vehicle at nhtsa.gov

During a severe, multi-lane impact crash, the second-row outer seatbelts completely failed to maintain restraint and failed to retract. Both occupants in the second-row outer seating positions (ages 5 and 7) sustained visible seatbelt friction burns on their arms from the initial impact, but immediately following the crash, both seatbelts were found completely broken, with all slack pulled completely out and zero mechanical retraction. Both children were found entirely unbuckled and unrestrained immediately following the impact. This vehicle is a Ford Explorer, and this failure matches the exact criteria of an active manufacturer safety recall noted on my insurance documentation (NHTSA Campaign ID: 26V159000 / Ford Recall No: 26C18) regarding second-row outer seatbelt anchor bolts being improperly secured. The vehicle has been declared a total loss, but the components are preserved and currently available for inspection upon request under a temporary insurance evidence hold. How safety was put at risk: The safety of two young children was severely compromised. Because the second-row seatbelt mechanisms or anchor bolts failed mid-crash, the children were left entirely unrestrained and unbuckled inside a moving, colliding vehicle after the initial impact, vastly increasing their risk of severe secondary impact injuries. Has the problem been confirmed by a dealer/independent center? UNKNOWN. The failure occurred during the crash, and the vehicle was towed directly to a holding lot. Has it been inspected by others? The vehicle has been documented by insurance representatives for valuation purposes, but a dedicated mechanical inspection of the failed seatbelt components has not yet been performed. Were there warning lamps or prior symptoms? NO. There were absolutely no warning lights, messages, loose seatbelt components, or mechanical symptoms prior to the crash. The system appeared to be functioning normally until it failed under the stress of the impact.

Source: NHTSA complaint ODI #11744835 · view all complaints for this vehicle at nhtsa.gov

The problem with my car is that I replaced the catalytic converter four months ago; I used an original part from the dealership. I am very concerned that the catalytic converter has failed again after only four months. I am convinced that the manufacturing process is flawed or defective. I am afraid something serious might happen to my only car, or that this could happen to someone else. I urge you to investigate what is going on with Ford, as there seem to be constant recalls for their vehicles. I am lodging a complaint because this has happened to me twice now. Furthermore, I only use Shell gasoline; I don't know what else to do, and I am asking for help.

Source: NHTSA complaint ODI #11763268 · view all complaints for this vehicle at nhtsa.gov