10r140 paired with 6.7 powerstroke in a 2020 f250 build date 11/19 at the Kentucky plant. My truck specs and build date and location is in the timeframe of the planetary gear recall, ford has also issued tsb’s about the cdf bushing that should have been a recall because it is a design flaw on every 2020-2022 model truck. It’s not fair that we should have to pay for a tsb bc we don’t have warranty left. My truck has 84,000 miles but is out of the 5 years warranty period. Symptoms I am having with my transmission are: Harsh engaging to drive and reverse Flair shifts bad sometimes almost like it goes into neutral between changing gears Has shifted from 4th to 1st instead of 4th to 5th or 6th, then it started shifting normal right after. Had my factory 3250rpm limiter not been moved to 4500rpm the truck would have locked the rear wheels up and possible caused driveline damage or other damaged. Also had a car been behind me when this happened I would have been in a wreck because it slammed to a low speed and the car would have rear ended me. Slips in 4th and 7th gear the most but sometimes in other gears Bumps when it shifts a lot of the gears Sometimes shudders and shakes and will almost make like a pop noise Will clunk on downshift from 5-3 Sometimes clunks when upshifting 3-5 I have had the truck looked at by an independent diesel mechanic I use and he said there is a problem somewhere in the transmission, it’s either planetary gear or cdf bushing has moved or the drum itself has cracked. The component itself has not been inspected because the only was to inspect this is to tear the transmission down. The pan has been dropped and had a lot of metal material on the magnet. No codes on the dash but my mechanic said I had dtcs stored for the transmission. I have created a case claim with Ford trying to see if they will extend the recall for the known issue but I have had zero luck with them. I have videos of the issues but can’t upload them on here.

Source: NHTSA complaint ODI #11752304 · view all complaints for this vehicle at nhtsa.gov

Vehicle: 2020 Ford F‑250 Super Duty VIN: [XXX] Issue: Front / CHMSL camera intermittent or inoperative Ford CSP 20B39 applies CSP cannot be completed due to Gateway Module failure Ford has not responded despite multiple written requests I have personally sent emails to them on: Sent April 6 Sent April 9 Sent April 16 4/29 - Called and asked for coordination. Received no acknowledgment RE: Request for Coordination With Dealer to Complete Recall 20B39 [XXX] [XXX] > Thu, Apr 16, 11:59 AM (13 days ago) to crcfmc, [XXX] , [XXX] , [XXX] Dear Ford Customer Relationship Center, I'm writing to follow up again on my previous emails of April 6 and April 9 regarding my 2020 Ford F-250 Super Duty (VIN: [XXX] ). I have not received any response or confirmation of receipt. I want to correct my earlier characterization — after further research, I understand that 20B39 is a Customer Satisfaction Program, not a safety recall. That said, the core issue and my position remain the same, and I want to lay out where things stand clearly. The situation: - My vehicle is covered under CSP 20B39 (Front View and CHMSL Camera — PCB conductivity issue causing intermittent camera operation) - The program is in effect through November 30, 2030 or 150,000 miles, and the repair is to be performed at no charge to the vehicle owner - My servicing dealer, Santa Margarita Ford, attempted to complete the CSP work but could not because the vehicle's Gateway Module is not communicating properly - The dealer has advised that the Gateway Module must be replaced before the camera work under XXX can be completed My position: Ford issued CSP XXX and committed to completing this repair at no charge. If the Gateway Module must be functional in order for Ford's own program to be executed, then resolving the Gateway Module issue is Ford's prerequisite to meet — not an out-of-pocket cost to push to the customer. I'm not asking for anything beyond INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Source: NHTSA complaint ODI #11734594 · view all complaints for this vehicle at nhtsa.gov

This vehicle was delivered yesterday to my son through Autonation Sanford [XXX] . The CARFAX report stated a pre delivery inspection was done prior. On the way home he experienced loud screeching from the front wheels. Turns out $1650 later he needed new brakes and rotors. That is negligence, and fraud, especially with a commercial vehicle intended on towing a fishing boat. This was underhanded and a disgusting pattern of behavior. In addition, the open fixable recall was NOT completed as we just found out from searching the VIN on your website. The managers name is [XXX] , I have reached out to him to rectify this situation, and no call back. Truly grotesque, taking advantage of a [XXX] kid. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Source: NHTSA complaint ODI #11728224 · view all complaints for this vehicle at nhtsa.gov

The contact owns a 2020 FORD F-250. The contact received notification of NHTSA Campaign Number: (25V626000 (STEERING) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Source: NHTSA complaint ODI #11741499 · view all complaints for this vehicle at nhtsa.gov

Left rear seat belt buckle or system failed causing a fault in the Airbag/Restraint system. The fault initially happened in June of 2025 with about 50k miles on the vehicle. I took it to a dealer who told me the buckle was not available and the whole system needed to be replaced for over $1500. Vehicle seldom has anyone in the back seat but that is where my children sit. Looking at posts on the internet, this seems to be a common enough problem that this should be taken care of under recall or customer service warranty.

Source: NHTSA complaint ODI #11743890 · view all complaints for this vehicle at nhtsa.gov

Component: Air Conditioning / Heater Subject: Recurrent HVAC System Failure - Passenger-Side Temperature Control Malfunction I am reporting a recurring failutre of the vehicle's HVAC system affecting the passenger-side temperature control. Specifically the passenger-side air vents intermittently and repeatedly blowing hot air while the driver-side continue to operate normally with cooled air. This condition results in inconsistent cabin temperature control andrenders the air conditioning system ineffective for occupants on the passenger side. Timeline of Failures and Repairs: July 2023: Initial occurrence of passenger side hot air condition. Vehicle was taken to authorized Ford dealership (McRee Ford). Repairs were performed; however the specific root cause either identified or not permanently corrected as another recurrence happened August 2025: Took it back to McRee Ford due to an identical issue reoccurred where the passenger side was blowing hot air. They attempted to repair with the same technician and was again only a temporary resolution as the issue again occurred March 2026: Passenger side blowing hot air for the third time. Took it to a different authorized Ford dealership (Cook Ford) where again, it was identified as a blend door actuator issue. Safety Concern: While the issue may appear to be a comfort concern, it presents a potential safety risk in high temperature environments such as Texas. (Heat related stress or illness for passengers) Multiple authorized dealership seem to be unable to resolve the issue. Currently vehicle is with Cook Ford and was advised that additional funding would be needed for a permanent fix. I've already been financially burdened with taking the vehicle twice to McRee Ford and now a third time to Cook Ford for the same issue, and being told upfront that the failure may again happen. I request an investigation into this matter and HVAC issue. Thank you.

Source: NHTSA complaint ODI #11727893 · view all complaints for this vehicle at nhtsa.gov