Vehicle Safety Complaint – 2021 Ford F-350 I am submitting this complaint regarding a safety-related failure involving my 2021 Ford F-350. While driving under normal conditions, the vehicle suddenly entered “limp mode,” resulting in a significant and immediate loss of power. Approximately 20 miles later, the vehicle completely shut down, leaving me stranded and requiring the truck to be towed to Gene Messer Ford for diagnosis and repair. The failure created a potentially dangerous situation, as the loss of power limited my ability to maintain safe speeds and respond to surrounding traffic conditions. After the vehicle was delivered to the dealership, it took approximately one week for inspection and an additional two weeks to complete repairs. During the repair process, I was informed that newly installed components—including the fuel rail and two fuel injectors—were defective and required replacement again. This raises concerns about whether the root cause of the failure was properly identified and whether contamination or systemic failure within the fuel system was present. I am also aware of widely reported issues involving high-pressure fuel pump (HPFP) failures in Ford diesel engines, which can result in catastrophic damage to the entire fuel system, including injectors, fuel rails, and lines. Given the nature of my vehicle’s failure and the components involved, I am concerned that this incident may be related to a broader, known defect. This type of failure—sudden loss of power followed by complete shutdown—poses a serious safety risk, particularly if it occurs at highway speeds or in high-traffic conditions. I am requesting that this complaint be reviewed as part of a broader investigation into potential fuel system defects in Ford diesel trucks. I believe this issue may warrant further scrutiny and possible recall action to prevent similar incidents.

Source: NHTSA complaint ODI #11735094 · view all complaints for this vehicle at nhtsa.gov

I was driving my truck home when it completely shut off, I lost all power to everything, including the power steering brakes. When I got home, I did some research on the Internet to see possible causes. Apparently there is a service bulletin for the fuse box having water getting into it from the cowl of the hood, which states it can do exactly what happened to my truck? You can also keep your truck running and not shutting off and just to hold host of other safety issues with the service bulletin. . So I brought my truck in to get diagnosed by Ford and they did indeed say it was the fuse box under the hood that got water into it and shorted it out. Ford would not cover this part even though I have a factory extended warranty, annoying this is a common issue for 2020 to 2022 Ford trucks they issued a recall on expeditions in a couple other vehicles, but not Ford trucks specifically the super duties. How is this? OK that they don’t tell a customer who purchased a vehicle that this could potentially happen and then when it happens, they refuse to cover anything even though it’s their fault why it happened.

Source: NHTSA complaint ODI #11749077 · view all complaints for this vehicle at nhtsa.gov

The contact owns a 2021 Ford F-350. The contact stated that while driving at speeds above 40 MPH and attempting to depress the brake pedal, the vehicle slid and drifted to the right. There was no warning light illuminated. The vehicle was taken to a local dealer where it was diagnosed, and the contact was informed that the grease pins needed to be greased. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 44,000.

Source: NHTSA complaint ODI #11691277 · view all complaints for this vehicle at nhtsa.gov

Death wobble: while driving approximately 60 MPH over a bridge and construction zone over rough pavement the steering oscillated rapidly and I drifted into another lane applied the brakes causing other vehicles to swerve and emergency brake. This occurred [XXX] in Denver Colorado.

Source: NHTSA complaint ODI #11633920 · view all complaints for this vehicle at nhtsa.gov