When we brought it in for first oil change at the dealership ; when we got it back it had a broken axle which they tried to say we just needed new tires , after contacting service manager and he and I go for a ride in it they kept it for several weeks and put over 300 miles on it and got ford engineering involved to determine the cause was broken axle. It has been replaced again since then supposedly by a recall but it feels like it is broken again ! Ford took some shortcuts and used inferior parts, infrastructure etc , we had tremendous problems with the battery to which they said their shouldn’t be any reason for this be happening loss of power loss of electrical display and distribution finally I just had to replace the battery on my own because they refused to accept responsibility 4-6 months later a recall for the batteries was issued. The axles on the truck are not sufficient and they are not taking care of it properly! I would also like to report that they cut so many corners on the Maverick that the tailgate just drops no shock absorber nothing just slams on the bumper very dangerous! & They also chose to leave many open” holes” where mud rocks , leaves etc get into the front quarter panels from the hood area at the corner of windshield . So this wet material gets trapped in there n I’m sure will eventually affect the structural integrity of the panel - maybe rust through! Same thing happens with the tailgate fills with debris from bed , rear wheel wells also have a whole. I just wish ford would go back to how Henry Ford ran the company ! Help NHTSA

Source: NHTSA complaint ODI #11736807 · view all complaints for this vehicle at nhtsa.gov

The contact owns a 2022 Ford Maverick. The contact stated that while driving at an undisclosed speed, the trailer brakes became inoperable. There was no warning light illuminated. The contact was informed by another driver that the trailer brake lights were not illuminated while the vehicle was stopped. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 44,700. The VIN was not available.

Source: NHTSA complaint ODI #11721686 · view all complaints for this vehicle at nhtsa.gov

I am getting a “rear seat belt monitor fault” warning on my dash accompanied by an air bag warning light. It is also not allowing the auto start stop function to work as the vehicle states it cannot verify the driver seat belt is fastened. I have read in online forums that this is not an isolated issue.

Source: NHTSA complaint ODI #11685134 · view all complaints for this vehicle at nhtsa.gov

The driver's side (left front) door failed at the check-arm attachment point inside the door assembly: the spot welds securing the check-arm reinforcement bracket to the inner door structure cracked and separated. The vehicle is a commercial fleet 2022 Ford Maverick XL SuperCrew with approx. 82,000 miles. The vehicle and failed component are available for inspection upon request. First symptoms were difficulty opening and closing the door with popping/cracking noises. No warning lamps or messages occurred; the failure is concealed inside the door. This is a safety risk because the check arm attachment supports the door's structure. The same weld separation on related vehicles has been documented by NHTSA (investigation PE23-013) to cause doors that fail to latch, fail to stay closed, or open while driving, risking occupant ejection and injury. The failure was confirmed 7/17/2026 by Grapevine Collision Center (Grapevine, TX) after a Ford dealership stated there is no recall or warranty coverage for the Maverick and referred me there. The shop diagnosed broken check-arm welds and quoted $2,602.46 for a door shell replacement, noting it has seen this identical failure on Ford Escapes and Lincoln Corsairs. Not inspected by Ford, police, or insurance. This is the same failure mode NHTSA investigated on 2020-2021 Escapes (PE23-013), which Ford addressed via Customer Satisfaction Program 23B56 covering 2020-2023 Escapes. The Maverick shares the same C2 platform and door design but is excluded, leaving owners to pay out of pocket for a defect Ford repairs free on sibling vehicles.

Source: NHTSA complaint ODI #11751291 · view all complaints for this vehicle at nhtsa.gov

Ford has 25N09 addressing the axles for the 2022 Ford Mavericks built later in the 2021 year, but mine was built in September of 21. I have axle issues as well, and this is the first vehicle I've ever had that's this new and has clunking in the CV axles. Mine clunks loudly, and the truck has 114k on it.

Source: NHTSA complaint ODI #11740369 · view all complaints for this vehicle at nhtsa.gov