At 3k miles the turbocharger and parts within the transmission failed on my 2025 ford maverick, there were no warning lamps or messages on the dash but I had the symptoms of lack of power, the truck struggled to climb hills, it sounded like the turbo sound was coming through the air vents, and going uphill it almost stalled. I took it to one ford dealership who claimed it was normal operation before taking it to one of Fords commercial truck centers who diagnosed a turbo failure and various parts within the transmission have failed.

Source: NHTSA complaint ODI #11760204 · view all complaints for this vehicle at nhtsa.gov

A year ago while driving on the interstate, my Ford Maverick suddenly threw a "Stop Safely Now" alert. I was able to turn the ignition off and back on to safely exit the highway. The alert came back once I made it to a parking lot and stuck around for a while. I was able to get it started and drove to a Ford dealership that told me it was just a software update. The same issue happened 2 more times before I made it to my destination after leaving the dealership, showing that it actually wasn't caused by a missed software update. Returning from my trip it happened 4th time. Afterward, the issue seemed to go away. Now a year later I got in the Maverick to leave work and the alert came back. I was not able to get it started and will attempt to get it over to a Ford dealership tomorrow to be seen for what seems to be the same issue, only worse if it still is not starting in the morning.

Source: NHTSA complaint ODI #11746575 · view all complaints for this vehicle at nhtsa.gov

The contact's employer owns a 2025 Ford Maverick. The contact stated that while driving approximately 45 MPH, the pre-collision warning light suddenly activated, and the vehicle abruptly stopped. After pulling over and waiting for several minutes, the contact was able to continue driving. The contact also had whiplash from the failure, and medical attention was needed. The contact mentioned completing 12 sessions of physical therapy. The vehicle was taken to the dealer but was not diagnosed or repaired. The dealer was unable to duplicate the failure. The failure reoccurred a week later while driving approximately 30 MPH. The manufacturer was not made aware of the failure. The failure mileage was approximately 3,000.

Source: NHTSA complaint ODI #11753287 · view all complaints for this vehicle at nhtsa.gov

Front driver airbag did not deploy. Vehicle has been totaled and may not be available for inspection. Driver seatbelt tightened requiring an X-ray due to chest pains. Ford has ignored complaint. Unsure if police or insurance inspected though both questioned the airbag not deploying.

Source: NHTSA complaint ODI #11704892 · view all complaints for this vehicle at nhtsa.gov

The passenger side floor is soaking wet every time it rains. Google says this is a defect with the windshield cowl, which other owners say is a common problem. Our safety is at risk with potential for mold, rust, and water intrusion into the electrical system. The truck is going to the dealership on Monday to have this issue addressed. It has been reproduced every time it rains. It has not been inspected by anyone other than myself. There were no warnings or alerts. We've noticed the wet carpet a couple times and researched the problem.

Source: NHTSA complaint ODI #11728937 · view all complaints for this vehicle at nhtsa.gov

Pre-collision system became unavailable. System reported camera obstruction, but windshield was clear. Similar to issues in August 2025. August issue was temporary fixed via software update and reset at dealership. Suspect recurring software or physical issue with safety equipment.

Source: NHTSA complaint ODI #11700636 · view all complaints for this vehicle at nhtsa.gov