My 2022 Ford Maverick Hybrid has twice suddenly entered limp mode and experienced a substantial loss of power. The first incident occurred on or about XXX. After leaving my subdivision, I turned onto [XXX], which has a posted speed limit of 55 mph. The vehicle immediately lost power and entered limp mode, and the engine and wrench warning lights appeared. The weather was clear and sunny. I was able to drive several miles at substantially reduced power and return home. On XXX, at 83,600 miles, Louisburg Ford retrieved DTC P1061, determined that Ford TSB 25-2454 applied, and reprogrammed the required modules. The second incident occurred on 9/13/2026. My husband and I were returning home after traveling through [XXX], [XXX], and [XXX]. We were driving northbound on I-35 near mile marker 182 at the [XXX] exit, just south of [XXX]. It was completely dark and storming, with rain and lightning, when the vehicle again entered limp mode and lost power in highway traffic. We were fortunate to have cellular service and a gas station nearby. Otherwise, we could have been stranded in dangerous conditions. On XXX, at 106,338 miles, the same dealer retrieved the same P1061 code and again applied TSB 25-2454 by reprogramming the PCM. The same loss-of-power condition, code, and Ford-prescribed repair recurred within approximately 11 months and 22,738 miles. The dealer advised that there is no guarantee it will not happen again. I am concerned that this sudden loss of acceleration or motive power could recur at highway speed and cause a crash. I request that NHTSA investigate this recurring condition and whether TSB [XXX] provides an adequate remedy. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Source: NHTSA complaint ODI #11764238 · view all complaints for this vehicle at nhtsa.gov

I have a 2022 ford maverick pickup truck and have a vibration in steeling wheel at acceleration so I took it to a very reapable tire ,brake and suspension dealer who checked the brakes, tires, balance, steering joints etc and found nothing wrong and said he had no clue what it could be and no Ford Recall issued but web sites show other customers with same problem and dealers are not wanting to completely check out because of no Recall please help us!!!

Source: NHTSA complaint ODI #11664704 · view all complaints for this vehicle at nhtsa.gov

Driving on highway, approximately 65mph when all of a sudden the "door ajar" symbol on instrument panel lit / sound dinged, and the passenger who had their elbow on the door screamed. The passenger side door unlocked and "opened" as in it unlatched. It did not open all the way for her to fall out, but it was no longer fully closed. This is a 2022 vehicle. This happened for the first time in 2026 after 34k miles. There is an active recall for the same make / model but for some reason my VIN is not included. I'm pretty sure it should be after this experience.

Source: NHTSA complaint ODI #11750284 · view all complaints for this vehicle at nhtsa.gov

I have already had the cv axles replaced under the extended customer satisfaction program in January 2026, but today while doing a cross country move, the outer boot on the drivers side showed significant grease loss, and the inner boot on the passenger side tore off with a very severe clunk, noise, and shake while braking and accelerating. Thankfully the cv axle did not separate, but a failure could have resulted in a loss of control. This will be going to the dealership tomorrow. No warning lights, messages, or symptoms that I could observe before the 1000 mile trip across yesterday and today.

Source: NHTSA complaint ODI #11764584 · view all complaints for this vehicle at nhtsa.gov