I am reporting a recurring shudder/vibration condition in my 2024 Ford Maverick XL Hybrid. The vehicle currently has approximately 62,241 miles. The problem occurs during acceleration, generally between approximately 15 and 60 mph and started at just over 60,000 miles. The vehicle develops a pronounced shudder/vibration that feels similar to driving over a rough road or a rumble strip. The condition is repeatable and occurs during normal driving and acceleration. There are currently no warning lights illuminated and, to my knowledge, no diagnostic trouble codes have been identified. I am concerned that this may represent a drivetrain or transmission-related defect that could affect the safe operation of the vehicle, particularly if the condition worsens or results in a loss of smooth or predictable acceleration. I have become aware of Ford SSM 54797, which was issued in 2026 and addresses 2022–2026 Ford Maverick vehicles equipped with the 8F35 transmission. The service message states that affected vehicles may exhibit a shudder condition, most noticeable at speeds below 60 mph, with no relevant diagnostic trouble codes stored in the powertrain control module. It identifies the torque converter as a possible cause and provides a repair procedure involving the torque converter and related transmission components. The symptoms I am experiencing appear similar to the condition described in this Ford service communication. The vehicle is now just outside its applicable warranty coverage, which also makes it important to me that the condition be documented with NHTSA. I am requesting that NHTSA record this complaint and consider whether similar complaints involving the 2022–2026 Ford Maverick indicate a broader safety-related defect or trend.

Source: NHTSA complaint ODI #11764730 · view all complaints for this vehicle at nhtsa.gov

"This is a formal complaint for an Inadequate Recall Remedy and severe Consequential Damage regarding NHTSA Campaign #24V684000 (Ford Recall 24S59) on my 2024 Ford Maverick XL (65,000 miles, VIN: [XXX]).The official safety recall update was originally performed at 30,000 miles by a Ford mobile service unit, but the remedy completely failed. The Audio Control Module software remains corrupted, causing a severe intermittent parasitic drain. The radio frequently locks up, and roughly once a week, it remains actively powered on for 10 minutes after the ignition is turned off, keys are removed, and doors are locked. This has permanently destroyed my 12-volt battery, forcing me to rely on a trickle charger daily.On XXX, I took the truck to Mt. Orab Ford (Ohio) under Invoice #XXX for a separate recall (Ford 26C10). They completed the hitch recall but explicitly refused to address the failed safety recall 24S59 or the resulting battery damage. The official invoice they handed me falsely logs line item B as 'GBATT BATTERY TESTED GREEN AT THIS TIME.' However, I forced the Service Manager, Kevin Wilmoth, to physically verify the battery in the parking lot. The handheld tester printout he handed me directly contradicts their official invoice, explicitly stating 'GOOD RECHARGE' with a resting voltage of only 12.16V and a 45% State of Charge. A healthy 12V battery should rest between 12.6V and 12.8V; at 12.16V with a 45% charge, the system is severely drained and starved for power. The dealership printed 'Tested Green' on the invoice before actually testing it, and Kevin Wilmoth has since refused my email request for copies of the vehicle's OASIS history and FDRS global diagnostic logs to withhold the electronic record of these faults.Contacted Ford Corp., given a claim #, promised call back in 24hrs.completely failed to respond, leaving me stranded with a severe, un-remedied safety hazard. Requesting into Ford's failure to provide a free, functioning saf INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Source: NHTSA complaint ODI #11752718 · view all complaints for this vehicle at nhtsa.gov

1. 50% of my braking results in grinding stop where it jumps and doesn’t stop all the way at first, this is even driving at slow speeds of 25 mph. 2. When my truck was set on cruise control approx 70mph and all of a sudden started decelerating on its own and nothing I did made it accelerate. I had to coast/slow brake to pull over, cut the car off and then restart it to begin driving again.

Source: NHTSA complaint ODI #11762179 · view all complaints for this vehicle at nhtsa.gov

SENCE PURCHACED the truck has a tie rod rattle, I have spoken to dealership and was informed no issue found. But as of late Vehicle wobbles very harshly when execrating or pulling away from stop signs passing another vehicle. Turns out it's a VERY common CV axle issue that the dealership doesn't have any sort of recall on. Feels very very unsafe to drive and its disappointing to see so many other drivers with the exact same issue with the tie rod ends. Now a recall on some of the mavericks suspension AKA tie rod installed wrong/ defective with a DO NOT DRIVE WARNING?

Source: NHTSA complaint ODI #11742520 · view all complaints for this vehicle at nhtsa.gov

Restraints indicator warning lamp for passenger side went off repeatedly in August (four times). Took into dealership where they replaced what they said was a faulty seatbelt tensioner. Now, the same indicator warning is going off again, two times, 9/28, 10.4. Either the part is still bad, or the sensor is defective. I suspect the latter, but it's hard to know.

Source: NHTSA complaint ODI #11691542 · view all complaints for this vehicle at nhtsa.gov

Defective spot welds of interior door hinges bind resulting in destruction of 3 remaining spot welds making door inoperable, not closing correctly, damaging other hinge and locking mechanisms. Local and corporate denied. out of warranty at 42645 miles.

Source: NHTSA complaint ODI #11761776 · view all complaints for this vehicle at nhtsa.gov