Summary: My 2025 Ford Mustang Mach-E GT has repeatedly experienced a complete and unexpected loss of propulsion while driving in active traffic. Each time, the vehicle displayed a red “Stop Safely Now” warning with additional critical alerts, followed by an immediate loss of forward motion with no prior indication. This left the vehicle stalled in traffic and created a significant safety hazard. Details of Each Incident: While driving under normal conditions or coming to a stop, the vehicle triggered the red “Stop Safely Now” alert with powertrain and brake warnings. Propulsion shut down instantly and the vehicle locked in Park, leaving it immobilized in traffic lane. I had to exit the vehicle and wait for it to complete a full power-down cycle before it would restart. After restarting, the vehicle operated with reduced functionality and limited range. Ford Roadside Assistance was contacted for every incident. Safety Concern: A sudden loss of forward motion in moving traffic poses a serious crash risk to me and to other drivers. The repeated nature of this failure suggests a defect in the propulsion system, sensors, electrical components or related modules. Current Status: The vehicle is now at the local Ford dealership for evaluation. I have also notified Ford Corporate Customer Care. The root cause has not yet been identified or resolved. Requested Action: I request that NHTSA document this complaint and consider further review due to the recurring safety-related failure and the potential risk to other owners.

Source: NHTSA complaint ODI #11704393 · view all complaints for this vehicle at nhtsa.gov

Dash completely turned off. We could not see speed, gear, battery life, etc. See attached photo of the dash board above the steering wheel. Tried turning car off and on, tried resetting the monitor. Dealership service advisor witnessed this. The technician could not replicate it, and they did not have a solution but it is now back on. Worried it may happen again, opened up a buy back claim but dealership thinks we don’t have a strong case since they couldn’t find anything.

Source: NHTSA complaint ODI #11706310 · view all complaints for this vehicle at nhtsa.gov

I was driving normally at about 45 mph with no strong acceleration, after about 20 minutes of driving... Then Cross Traffic Alert, Crash Alert, ABS Failure Alert, Parking Brake Fault Alert, and probably more alerts suddenly went off while driving. Warning Lights for all these features stayed on, and I completely lost regenerative braking and power braking. I'm not sure if I lost anything else because I immediately pulled over, having to stand on the brakes to slowly stop. Once at a stop, I put it in park and warnings about parking brake faults continued to go off. I turned off the car, and warning about a parking brake fault continued to go off. I waited a few seconds and then opened the door to force the normal system shutdown. I pressed the brake and hit the start button again, but it didn't seem to recognize that I had pressed the brake and started in accessory (ACC) mode. After a few more second, I pressed the brake again and hit the start button (while still in ACC Mode), and the vehicle moved to full running mode without all of the warnings. This situation could have easily resulted in a full crash if I were driving at a faster speed and/or if I required immediate stopping.

Source: NHTSA complaint ODI #11742703 · view all complaints for this vehicle at nhtsa.gov

I noticed that I kept receiving a low tire pressure warning on my car. I would have it filled and then a few days later, the warning appeared again. I took the car in to the dealership to let them know there is an issue with my tire on 11/24/2025. The dealership then stated that I had to pay for a replacement tire. I asked if there was any type of warranty on the tire as I have only had the vehicle for a few months. They stated I had to purchase a new tire. I do not feel that I should pay for a defected tire. I have not driven the vehicle due to safety and want help in resolving this issue as the defect should be covered.

Source: NHTSA complaint ODI #11708431 · view all complaints for this vehicle at nhtsa.gov

On Thursday, May28 I was driving my 2025 Ford Mach-2 on Schrock Rd. in Columbus, Ohio at approximately 3:30 PM when the hood (the "frunk") of the car unexpectedly unlatched and opened, flying up to a vertical position and obscuring my view of traffic. I was driving in the left lane of this road at 40-45 mph. My view of the road was immediately obstructed, but I was able to crouch sufficiently to see enough of the road ahead and the mirrors on each side to navigate to the right lane and then to the side of the road, pull off safely, turn the car off, exit, and close the frunk firmly. I was away from home when this occurred. When I got in the care to drive home, there was a warning that came on, for the first time, that read as follows: FRUNK FAULT DETECTED; SERVICE REQUIRED. There was no advice to avoid driving the car. I checked the hood/frunk to be sure that it was firmly closed, then started for home, avoiding my usual freeway drive at 65mph for a slower trip on local roads. It is a good thing I did, because the risk of a major accident with injury and serious property damage would have been far greater at higher speed. I arrived home without the frunk opening again, called for Ford Roadside Assistance, and arranged to have the car towed to Germain Ford of Columbus, where it still is, awaiting the delivery of a new frunk latch system. The dealer has determined that there is likely a defective sensor in the frunk latch. This is a known issue with the Ford Mach-e, affecting not only the frunk but also sometimes the hatch lid in the rear.This is a serious safety hazard, and a review of reports over several models years from Mach-e owners indicates that I am not alone in having experienced it. At highway speeds a suddenly unlatched frunk/hood would not only open to the vertical, but conceivable also be smashed against the windshield or ripped off the vehicle and become airborne. Ford is aware of the issue, for there is are technical service bulletins covering it.

Source: NHTSA complaint ODI #11741785 · view all complaints for this vehicle at nhtsa.gov

Spitzer Ford in [XXX] sold me a new 2025 Ford Mustang Mach E with an open recall. I purchased the vehicle on xxx and this recall had been open and active since 1/26/26. 2 days after buying the vehicle xxx the dealership started calling me about an open recall that needed fixed. I was told by the dealership that they could not list the car as sold with Ford until the recall had been adjusted and they were waiting on a $4,000 rebate. If this recall was open since January, known to the dealership, and aware that it was not fixed, how can they sell a brand new vehicle with an open safety recall. The recall was rectified by the dealership on xxxbut illegally sold me the car on xxx with the open recall. I would like somebody to contact the dealership and rectify the situation so they are not selling brand new cars with open safety recalls to other patrons. They openly admitted they couldn't list the car as sold through Ford until the recall was complete. I'm assuming because they sold a new car with an open recall. The sales manager was dismissive and then started telling me how much he was gonna have to put into my trade for them to sell it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Source: NHTSA complaint ODI #11743722 · view all complaints for this vehicle at nhtsa.gov