The contact owns a 2010 Honda Odyssey. The contact stated that while driving at an undisclosed speed, the battery warning light illuminated, and smoke was coming from under the front passenger’s side hood. The vehicle was driven to the residence and parked. The contact stated that moments later, smoke and flames were coming from underneath the hood of the vehicle, and the Fire Department was called to the scene. The contact was able to extinguish the flames using a water hose prior to the Fire Department arriving at the residence. While at the residence, the fireman disconnected the battery as a precaution. The cause of the fire was not yet determined. The local dealer was notified of the failure. The manufacturer was not contacted. The failure mileage was 182,697.

Source: NHTSA complaint ODI #11752167 · view all complaints for this vehicle at nhtsa.gov

I am reporting a recurring and dangerous brake system failure in my 2010 Honda Odyssey. Intermittently, when the vehicle is first started, the brake pedal becomes completely stiff and cannot be depressed at all. During these events, the brakes are effectively non-functional until the condition resolves, creating a serious safety hazard. This issue occurs without warning and has happened on multiple occasions. This defect is especially dangerous because it prevents normal braking operation at startup, increasing the risk of a collision if the vehicle is moved or if immediate braking is required. I have attempted to repair this issue extensively. The vehicle has been inspected by three separate repair facilities, including a Honda dealership. The following components have been replaced in an effort to resolve the problem: •Master cylinder •Brake booster •Rotors •Brake lines •ABS system Despite these repairs, the issue persists unchanged. I have spent over $2,500 attempting to fix what appears to be a systemic defect. The Honda dealership suggested the issue may be caused by air entering the brake lines when the vehicle is parked on a slope. However, this explanation is not consistent with normal automotive function, and similar vehicles do not exhibit this behavior under the same conditions. Given the repeated failure of major brake system components to resolve the issue, I believe this represents a defect in the vehicle’s braking system that could affect other vehicles of the same model. I am submitting this complaint due to the serious safety risk posed by intermittent loss of braking function and request that this issue be investigated.

Source: NHTSA complaint ODI #11729061 · view all complaints for this vehicle at nhtsa.gov

When having to slow down or stop quickly, the van starts to jerk back and forth and shake a lot and the car becomes very difficult to control. This is especially noticeable when going down hills such as I-70 in Colorado, I-15 in eastern California or mountain passes in the Sierra Nevadas, but also when coming around a corner on a freeway and the traffic is stopped. It would be very serious if driving and a child ran out into the street in front of the van. I recently learned that this has happened fairly frequently with Honda Odyssey vans. I have had to replace brake and strut parts and bearings multiple times. (gratefully the struts were still under warranty, so I only had to pay for labor the ensuing times.)

Source: NHTSA complaint ODI #11693962 · view all complaints for this vehicle at nhtsa.gov

A few years ago the driver's side rear sliding door stopped working. This seemed like a safety because, if there were ever an incident such as a fire, people would not be able to expeditiously exit the back two rows of the van. There were no warnings, the door just stopped working. I spoke with our mechanic about it and he stated that he had seen that with several Honda Odyssey vans. I had the door repaired. I recently learned that this had been an issue with other Honda Odyssey vans and wanted to let you know it had also happened to me.

Source: NHTSA complaint ODI #11693960 · view all complaints for this vehicle at nhtsa.gov