The engine required a short block replacement at approximately 40,000 miles. There was a severe knocking sound and the dealer diagnosed heavy scoring and abnormal wear present on the front bank cylinder walls. The result was excessive internal engine clearance and cylinder wall damage. Engine cylinder piston block holes were worn beyond spec. After 33 days the vehicle was returned and developed a growling/grinding noise when the AC was in operation and at lower speeds that followed the RPMs. Vehicle was returned to dealer and told sound was normal operation for this model and stated it was coming from AC Compressor. Independent shop verified 2 days later AC compressor was failing and possible metal contamination. AC compressor is backordered with no ETA. Advised to not use AC or Defroster to avoid seizing and causing serpentine belt to snap. Advised Honda Customer Care and assigned Case Manager who was made aware of knock and compressor failure and contacted dealer who stated vehicle could not be seen for 7 days due to being booked. Advised Case Manager of vehicle safety concern with internal engine failure damage and failing AC system and was denied emergency loaner or assistance and told it was all they could do. Vehicle now unsafe due to both with no timeline for fixing and known hazards due to severe engine failures and associated issues with main systems.

Source: NHTSA complaint ODI #11761063 · view all complaints for this vehicle at nhtsa.gov

when driving our 2023 honda pilot we stopped at traffic light the car shut off would not restart our front doors would open and close our back doors would not operate back tale gate door would not operate we had no4 way blinkers no lights totally dead auto. we were in middle of four lanes bumper to bumper traffic with no way to warn other drivers of our car break down. after short time a helpful driver pulled up behind us and used his auto to block us from traffic and used his 4 way flashers to warn other cars to go around us . police and tow showed up in appx 20 min. car was taken to WILLIAMS HONDA OF TRAVERS CITY MI.49685 they repaired car next day informed us battery shorted out when auto shut off activated at stop light. we had no indications of any issues with our vehicle it is 3 yr old with 40138 mi on it battery was out warrenty. williams installed newAGM100M BATT. our main safety issue is lack of 4 way warning or signal to other drivers.WE WERE LUCKY NO ONE REAR ENDED US AND WE DID NOT NEED BACK DOORS TO OPERATE . THANK YOU [XXX] AND [XXX] FROM SAULT STE. MARIE MI [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Source: NHTSA complaint ODI #11755632 · view all complaints for this vehicle at nhtsa.gov

The contact owns a 2023 Honda Pilot. The contact stated that while driving at an undisclosed speed, the brake pedal was unexpectedly engaged causing the vehicle to abruptly stop in ongoing traffic with no warning lights illuminated. The vehicle was taken to the dealer, where it was diagnosed that the front brake sensors had failed and needed to be replaced. The vehicle was repaired; however, the failure recurred on multiple occasions. The vehicle was taken back to the dealer. The vehicle not diagnosed or repaired. The manufacturer was made aware of the failure, and multiple cases were opened. The contact expressed concern that the vehicle was hazardous to operate and that the failure could lead to a catastrophic crash. The contact also stated that the vehicle was unsafe to drive with the contact and the contact’s child inside. The failure mileage was approximately 50,000.

Source: NHTSA complaint ODI #11737129 · view all complaints for this vehicle at nhtsa.gov

I own a 2023 Honda Pilot. On two separate occasions while the vehicle was being driven, the vehicle experienced multiple system warnings and a significant loss of steering assistance. The first incident occurred before July 16, 2026, at approximately 40,605 miles. While my wife was driving, multiple warning lights illuminated and the steering wheel suddenly became extremely stiff and difficult to turn, although the engine remained running. She was able to pull over, turn the vehicle off, and restart it. After the restart, the warning lights disappeared and the steering returned to normal. I brought the vehicle to John Eagle Honda of Dallas on July 16, 2026. The dealer's repair order documents: “CUSTOMER STATES MULTIPLE LIGHTS CAME ON WHILE DRIVING AND STEERING WHEEL GOT REALLY STIFF BUT VEHICLE WAS STILL RUNNING.” The dealer reported that it performed a battery check and charging-system test, found no stored diagnostic trouble codes, could not duplicate the condition during a test drive, and performed no repair. The problem occurred again on September 8, 2026, at approximately 42,511 miles while my wife was driving. Once again, the steering became extremely difficult to operate. During this second incident, my wife also reported that the brakes were not functioning normally. Multiple warning lights and system-failure messages appeared simultaneously. Photographs were taken of the instrument cluster before the condition cleared. One message specifically stated: “Electric power steering system problem. Steering assist not available. Do not drive.” Another stated: “AWD All wheel drive system problem. Only front wheels may be powered. See your dealer.” The instrument cluster also displayed additional warning indicators associated with other vehicle systems. This is particularly concerning because the failure has now occurred twice while the vehicle was being driven. Turning the vehicle off and restarting it has caused the symptoms and warnings to disappear.

Source: NHTSA complaint ODI #11763055 · view all complaints for this vehicle at nhtsa.gov

The 2nd row passenger side seat belt buckle sensor begins to report "un-buckled" status that cannot be remediated by re-buckling the belt. Honda replaced the same belt buckle twice already for the same issue. First defect manifested and was corrected by Honda 18 months from purchase, the second one - manifested and corrected 17 months after first one. NHTSA bulletin 26-027 describes this exact issue in detail.

Source: NHTSA complaint ODI #11759563 · view all complaints for this vehicle at nhtsa.gov

Known design defect under Special Coverage for some vehicles, but does not include my VIN for a 2020 Chevy Traverse. Full details are provided in the attachment, including photos of the broken exhaust weld bracket and costs incurred so far. Additional expenses are expected to be incurred in the coming days when parts are available to prevent exhaust emissions from entering the vehicle during operation while doors and windows are closed, which is an issue caused by failure of the exhaust weld bracket.

Source: NHTSA complaint ODI #11759404 · view all complaints for this vehicle at nhtsa.gov