The shift-by-wire system failed while the vehicle was being parked. The vehicle would not shift out of Drive; repeated attempts to engage Park resulted in Neutral only, with a "PARK malfunction. Engage parking brake when parking vehicle." warning displayed in the instrument cluster. Because this vehicle requires Park to be engaged before it can be powered off, the vehicle also could not be turned off. I was trapped with an energized vehicle that could not be secured in Park or shut down for approximately 30 minutes. A red 12-volt battery warning lamp was illuminated in the instrument cluster during the event (photo attached showing the malfunction message, Neutral gear state, and battery warning lamp). I secured the vehicle using the electronic parking brake. Safety risk: a vehicle that cannot engage Park or power off risks rollaway and leaves the driver unable to safely exit and secure the vehicle, particularly on a grade or in traffic. This is the second occurrence of a shift-to-park failure on this vehicle. The vehicle was previously taken to an authorized dealer for the same symptom; the dealer cleared diagnostic codes without repair and the problem recurred. The vehicle is scheduled for further dealer diagnosis and is available for inspection upon request. The ICCU recall remedy (Recall 272) was previously completed on this vehicle per the manufacturer's campaign records.

Source: NHTSA complaint ODI #11742125 · view all complaints for this vehicle at nhtsa.gov

My 2023 Ioniq 6 is not charging as it has for 3 years. When charging to 100% my app States 347 and 382 miles. It should be 361 as stated by Hyundai. What happens if I drive under 45 mph after 5 miles the miles goes down to 303. It is not working as stated. It is not holding miles properly.

Source: NHTSA complaint ODI #11742584 · view all complaints for this vehicle at nhtsa.gov

I was crossing the Mackinac Bridge, northbound, this afternoon, at the time traveling over the bridge deck's grates in the left lane. Traffic was backed up and I was traveling in the single-digit MPH. There was more that a car's length between myself and the next car ahead, and as I accelerated a little bit to close the distance my emergency braking activated. Fortunately, the car behind me was trailing by a little bit and was also traveling slowly.

Source: NHTSA complaint ODI #11678124 · view all complaints for this vehicle at nhtsa.gov

Subject: Safety Complaint – Sharp Upper Door Edge Causing Facial Injury (Hyundai IONIQ 6, 2023) Message: To whom it may concern, I would like to submit a safety complaint regarding my 2023 Hyundai IONIQ 6 (VIN: [XXX] ). On October 14, 2024, my wife suffered a facial injury caused by an extremely sharp upper edge of the front door. This occurred in our driveway at [XXX] . The injury happened when the front door stopped at its mid-detent position and the sharp, exposed upper edge made forceful contact with her forehead and the area next to her eye. She avoided a direct eye injury only due to quick reflex. This design presents a serious risk to passengers, especially those of shorter stature. I have photographic documentation showing the sharp door edge and the injury mechanism. Hyundai Motor America was informed, but they dismissed the case and advised us simply to “be more careful.” They offered a $150 virtual compensation card, which I did not use, because accepting it could be interpreted as accepting their proposed settlement. Hyundai insisted on dealer inspection, which is irrelevant because this is not a defect of a single unit — all vehicles of this model have the same door-edge geometry. I believe this is a safety-related design hazard affecting all Hyundai IONIQ 6 vehicles. I respectfully request that NHTSA review this case, as the risk of eye or facial injury is significant. Please let me know if you require additional information or photographs. Sincerely, [XXX] [XXX] Phone [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Source: NHTSA complaint ODI #11701885 · view all complaints for this vehicle at nhtsa.gov

The horn on my vehicle is defective after 16000 miles. I am available to take it in for an inspection. I was almost backed into and I had no way of alerting the other driver. This problem has not been reproduced by my local dealership but it has been at other national and international dealerships per forums. I am unsure if this component has been inspected by the manufacturer, police, insurance company, etc. This problem was random without warning which makes this even more of a safety concern since I had no clue this was defective until I actually had to use it.

Source: NHTSA complaint ODI #11647298 · view all complaints for this vehicle at nhtsa.gov