RECALL REMEDY FAILURE AND MANUFACTURER COERCION My Certified Pre-Owned 2022 Hyundai Sonata Limited has been held completely out of service at an authorized Hyundai facility since June 2, 2026, due to severe fuel tank expansion under active NHTSA Safety Recall 25V-796 (Hyundai Campaign 286).The dealership confirmed that the defective expanding plastic fuel tank ballooned with enough force to structurally warp and buckle the unibody center floor pan and frame rails. Rather than providing a safe, timely remedy under federal recall guidelines, Hyundai Corporate and the dealership are attempting to coerce me into an unfair, non-statutory "voluntary trade-in" that simply pays off my remaining loan balance ($22,000) while completely wiping out the $9,000 in cash equity ($3,000 down payment and $6,000 in monthly payments) I have invested into the car. Upon rejecting this predatory trade-in offer, the manufacturer immediately threatened an additional 6 to 8-week delay to attempt a massive structural frame and unibody pull, which would bring the total out-of-service time to over 90 to 110 cumulative days. Furthermore, the dealership is actively withholding the internal diagnostic write-ups and structural alignment prints from me. I am requesting that the NHTSA investigate this recall remedy failure. Hyundai is using extreme delays (90+ days) and structural frame threats to force consumers to abandon their financial equity rather than issuing lawful, purchase-price repurchases for vehicles deemed structurally unsafe due to a manufacturing defect. I can't provide any documents as they have refused being able to provide me with any. Was told I would be emailed a copy from the dealership several times and they never end up sending over any information.

Source: NHTSA complaint ODI #11754635 · view all complaints for this vehicle at nhtsa.gov

The Full stereo system with cameras and most sensors and the car is currently at the dealership as 03/09 @11:00 am and I took It to them as well so that they can repair the other pending recall I have at the moment and they stated that It was a " point to point check recall " and that they would change it whether it would need to be or not and I raised concerns about another possible recall on the car and if they could check it out which is my stereo system they tried to charge me almost $200 and " the symptoms or warnings " was that sometimes it would happen but Instead of It going out completely I was able to troubleshoot it by pressing on the little button under the volume button

Source: NHTSA complaint ODI #11722956 · view all complaints for this vehicle at nhtsa.gov

The contact owns a 2022 Hyundai Sonata. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 25V796000 (Fuel System, Gasoline); however, while driving 70 MPH and depressing the accelerator pedal, the vehicle decelerated unintendedly. The check engine warning light illuminated. The contact stated that upon depressing the brake pedal, the brakes failed to respond as intended. The manufacturer was notified of the failure and stated that the contact would receive a callback. The failure mileage was 140,000.

Source: NHTSA complaint ODI #11764526 · view all complaints for this vehicle at nhtsa.gov

I have had DTC codes since November 2022 for the TPMS system. I took the car to the dealership in Ocala, FL. The removed the codes and less than 10 minutes of driving they came back. I scheduled another appointment in Gainesville, FL they also were unable to resolve the issue. I contacted Hyundai and the case manager attempted to contact the Gainesville, FL dealership. They did not respond, the solution given is schedule another appointment myself...

Source: NHTSA complaint ODI #11534896 · view all complaints for this vehicle at nhtsa.gov

The contact owns a 2022 Hyundai Sonata. The contact stated that while driving approximately 65 MPH, there was an abnormally loud bang coming from the vehicle. Upon inspection, the contact became aware that the sunroof windshield visor had shattered. The vehicle was taken to a local dealer where it remained for further inspection. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 61,000.

Source: NHTSA complaint ODI #11753318 · view all complaints for this vehicle at nhtsa.gov

The driver's power seat drive cable on the left-hand track rail snapped internally. The motor only advances the right side, causing the seat to twist violently to the left and jam. This mechanical failure occurred prematurely at 9,000 miles. Because the seat framework is structurally compromised and twisting out of alignment, it poses a severe occupant safety hazard in a collision. And interferes with positioning the seat to operate the vehicle safely. The dealer has inspected the complaint and was able to reproduce the complaint. But did not cover it under warranty. There where no warning signs before the premature failure.

Source: NHTSA complaint ODI #11753307 · view all complaints for this vehicle at nhtsa.gov