The brake assist malfunctioned causing the brakes to abruptly stop without cause or warning. When the braking system abruptly stopped it caused a jack knife and lost of a trailer on a congested highway with vehicles in all lanes, I was able to finally get control of the tractor with out causing contact or injury with other vehicles and the rear trailer broke free and rolled back and landed in the grass that divided the highways. I injured myself and had to have surgery. The tractor was taken to a shop 4 days after the accident. They found that the module for abs ec80 had blocked radar and data link faults for camera, radar & camera was not properly installed. Rush truck center told the company that they needed to drive tractor on a long drive to recreate issues, but the company denied to go forward and picked the tractor up.

Source: NHTSA complaint ODI #11514699 · view all complaints for this vehicle at nhtsa.gov

I drive tractor trailer for JB Hunt. Over the last 4 Years, the three trucks I have been assigned to have had exhaust leaks that vented into the cab. One was a Freightliner (approx 2017 model), and two have been Internationals. These exhaust leaks caused me medical problems, requiring that I take off time unscheduled. The last three trucks I have been assigned to have had exhaust leaks into the cab. Some leaks I only found with a thermal camera. The exhaust leaks are not the main problem. The problem is that design of these trucks cause any leaking engine gases to be pushed into the cab of the truck, mostly through the air conditioning/heater vents. I have tested this. I zip tied a can of orange air freshener under the hood. The can was positioned in such a way as to point away from the air intake box, toward the back of the engine. When driving at highway speed, the orange air freshener was very strong coming into the cab from the a/c vents. The truck is supposed to be getting the fresh air from outside the truck, and forward of where the air freshener was spraying. I originally thought the only problem was that the cabin air intake box is located under the hood, in immediate proximity to all of the leaks. This in itself is a poor design. Even with duct tape over the openings into the cabin air box, any gases (or air freshener) is immediately pulled into the cab through the a/c and heat. I have no idea how this occurs. The design of the trucks allows any leaking gases under the hood to come directly into the cab. This applies to Freightliners and Internationals. They have the same basic design, and by experience I can say that both perform the same way. The hoods on both truck makes are designed with dedicated pathways to provide pure outside air for the intake of the ENGINE. The air provided to the driver comes from an unsealed airbox located under the hood. The main problem is not the leaks but that they get vented into the driver's cabin. The engine crankcase ventilation pours large volumes of exhaust gases and oil vapors into the engine bay of the truck. This is a design flaw. The crankcase exhaust exits to the inside of the frame, at the front left of the engine, approximately central vertically under the hood. This continually fills the engine bay with exhaust gases and vapors.

Source: NHTSA complaint ODI #11442614 · view all complaints for this vehicle at nhtsa.gov