I live in [XXX]. On the way to [XXX], out of no where the car stopped accelerating. Was in eco mode at the time and dropped completely while trying to accelerate in the middle of the road. Pulled over completely turned off the car checked the engine nothing seemed out of the ordinary. Ran the diagnostics from the car and didn’t show any errors. Turned off again for a bit and turn on and everything was fine. Moved from eco to smart and turned around worked fine for about 5 m so we thought everything was on and tried to go back north to finish our trip and while on smart mode started to accelerate again and didn’t want to accelerate. Turned around and decided best to take it to dealership Monday. We have about another 1 hour to 2 hours to get home and it’s working fine in smart mode but it shouldn’t randomly drop acceleration at all in the middle of driving. Only at 16,487 miles. Doing it again only driving 33 m an hour and in smart mode. Not even going uphill just dropped acceleration while driving around town. About 15 m after. There’s still no error happening when it happens each time. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Source: NHTSA complaint ODI #11748283 · view all complaints for this vehicle at nhtsa.gov

My vehicle keeps throwing a code “check hybrid system” and slowing me down to 30mph, it will not accelerate. This is extremely dangerous. I can restart the car and it’s fine but this is a major safety issue considering it keeps happening

Source: NHTSA complaint ODI #11762493 · view all complaints for this vehicle at nhtsa.gov

I had two very serious incidents. July 8th: Horn just started blaring unprompted. Locking/unlocking doors, turning motor on, disconnecting battery did nothing to stop it. I was trying everything and as I was trying to find the correct fuse to disable (it wasn't labeled), the horn burned out and started smoldering. If the car was not in my driveway AND I wasn't home, I believe a fire would have started if I didn't pull the fuse AND douse it with water. It was parked next to my garage, so that would have been at risk as well. July 11th: When driving, my brake line burst resulting in a complete failure of my brakes. I narrowly escaped two accidents before I realized something was amiss. But the only warning was ABS was inactive, and active cruise control wasn't working. I had no warning that complete brake failure was imminent. I was extremely lucky. Mechanics had never seen a brake failure fail in a relatively new car in very good condition.

Source: NHTSA complaint ODI #11752483 · view all complaints for this vehicle at nhtsa.gov

The passenger-side sliding door closed while I was holding my son and leaning into the passenger doorway. At the time the door was closing, my son’s left foot was still inside the doorway. The sliding door closed directly onto his left foot and remained fully closed on his foot rather than stopping or reversing. His foot was trapped by the closed door until we were able to open it. This incident resulted in significant bruising to his left foot and concern for a possible fracture. The failure of the sliding door to detect the obstruction and stop or reverse put my son’s safety at serious risk and resulted in injury. The component involved was the passenger-side power sliding door and/or its obstruction detection/anti-pinch safety system. The vehicle and door are available for inspection upon request. At this time, the problem has not been reproduced or confirmed by a dealer or independent service center. The vehicle/component has not yet been inspected by the manufacturer, police, insurance representatives, or others in connection with this incident. There were no warning lamps, warning messages, or other symptoms that we noticed prior to the incident indicating that the sliding door or its safety system was malfunctioning.

Source: NHTSA complaint ODI #11762863 · view all complaints for this vehicle at nhtsa.gov

I am writing to formally report a serious, recurring safety defect involving the Heating, Ventilation, and Air Conditioning (HVAC) system in my vehicle. The system intermittently shuts off completely without warning and suffers from a malfunctioning airflow diverter. This directly impacts driver visibility due to immediate windshield fogging or the inability to de-ice during cold weather conditions. Below are the logged details of the intermittent shutdowns: July 9: System shut off 22 minutes into the drive. Local time: 07:58. Ambient temperature: 76°F. Vehicle settings: 72°F, Fan Speed 3.July 11: System shut off 34 minutes into the drive. Local time: 17:10. Ambient temperature: 92°F. Vehicle settings: Low, Full Blast. Furthermore, the airflow diverter is partially stuck on defrost mode. Air constantly blows onto the front windshield regardless of the chosen setting on the selector. This uncommanded airflow creates rapid temperature differentials on the glass, causing severe condensation and clouding the driver's line of sight during operation. These compounding HVAC failures constitute a significant safety hazard by unexpectedly distracting the driver and severely reducing visibility. I request that these issues be documented and investigated for potential safety recalls. Currently, my vehicle is in the shop with a local KIA dealership. A KIA corporate service technician is on ground and investigating the electrical and HVAC issues. Feel free to reach out for additional observational notes that I have compiled.

Source: NHTSA complaint ODI #11756260 · view all complaints for this vehicle at nhtsa.gov