My 2024 Kia EV6 is experiencing a total failure of the 12V charging system and requires manual jumpstarts to operate. The official ICCU safety recall (SC327) was previously performed, which is why the NHTSA database shows 0 unrepaired recalls for this VIN. However, the manufacturer's remedy has completely failed. Per NHTSA safety guidelines, this vehicle is currently subject to a sudden loss of motive power while driving and is unsafe to operate on public roads.

Source: NHTSA complaint ODI #11762654 · view all complaints for this vehicle at nhtsa.gov

I got into my car in a hurry i put my car in drive as i was closing my driver's door and took off and because the door wasn't fully closed the parking brake engaged itself but the power over comes the parking brake, when i let off the throttle the rear wheels locked up causing the car to slide out of control. I pushed on the throttle again to unlock the rear wheels causing me to swerve in the other lane and almost crash into an incoming car. I tried to turn off the brake and could not without stopping the car so i had to skid out of control again stopping to turn it off.

Source: NHTSA complaint ODI #11763034 · view all complaints for this vehicle at nhtsa.gov

Rear tires on my 2024 Kia EV6 wore down to the tire wear-bar limit (2/32" remaining tread) at approximately 19,500 miles, while the front tires on the same vehicle measured roughly double that remaining tread (4/32") at the same odometer reading. The factory-installed tires are rated by the manufacturer for approximately 50,000 miles of tread life under normal use, so reaching the wear-out point on the rear tires alone at roughly 39% of that rated mileage is well outside expected wear for this vehicle at this mileage. This is not an isolated event: numerous other EV6 owners have independently reported the same front-to-rear wear disparity and premature rear tire wear online, across different driving styles and regions, which points to a vehicle characteristic (front/rear torque split, alignment or camber specification, or suspension geometry) rather than individual driver behavior. Uneven, accelerated rear tire wear reduces traction and increases stopping distance, and raises the risk of hydroplaning, tread separation, or blowout, particularly in wet weather, since the rear tires lose effective grip well before the front tires or before a typical maintenance interval would flag it. The wear was confirmed and documented, including tread-depth measurements at all four corners, by an independent third-party vehicle condition inspection performed at lease return. There were no dashboard warning lights or driver-facing alerts indicating the wear; it was only discovered through physical tread-depth measurement at that inspection. The tires inspection results are available upon request. This appears to reflect a design or specification issue affecting the vehicle's rear tires disproportionately, rather than a manufacturing defect isolated to one tire.

Source: NHTSA complaint ODI #11750683 · view all complaints for this vehicle at nhtsa.gov

When putting a car seat in and using the cars seat belt the rear seat belt buckles do not come up at a high enough angle and cause the belt to bind in the buckle for the lap and will not allow the belt to slide and be properly tensioned to hills the car seat to the bottom of the cars seat

Source: NHTSA complaint ODI #11763039 · view all complaints for this vehicle at nhtsa.gov