The contact owns a 2022 Kia Niro. The contact stated while driving at an undisclosed speed, the vehicle intermittently entered limp mode and loss automotive power while the vehicle was still at full battery. No warning lights were illuminated. The failure occurred on several different occasions. The vehicle was taken to a dealer to get a diagnosis however, the dealer stated that the failure was not duplicated. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 36,000.

Source: NHTSA complaint ODI #11737434 · view all complaints for this vehicle at nhtsa.gov

Component or system that failed: High-Voltage Electrical System / High-Voltage Battery Safety Plug Assembly (specifically covered under Recall SC314 / NHTSA Campaign 24V-358). It is NOT wear and tear as falsely claimed by the dealer. The vehicle is available for inspection upon request at the owner's residence. How safety was put at risk: The vehicle triggers an active "Check EV System" master warning while driving, creating a severe risk of sudden loss of motive power (stalling) on public roads. The high-voltage charging system is also completely disabled, leaving an elderly driver stranded without transportation. Has the problem been reproduced or confirmed by a dealer?: Yes. Rick Case Kia (Duluth, GA) inspected the vehicle from July 20–22, 2026. Instead of resolving the recall defect at $0.00, they falsely mischaracterized the electrical failure as "wear and tear / customer declined repair" and demanded $1,617 out-of-pocket before releasing the unsafe vehicle. Has the vehicle/component been inspected by others?: Inspected by [XXX] Case Kia service department. Opened active corporate case with Kia America (Case #XXX). Independent mechanics have confirmed this is not simple “wear and tear”, but deeper electrical issues that were touched during the recall. Warning lamps, messages, or symptoms: "Check EV System" master warning light and total failure of the high-voltage charging port. Symptoms first appeared shortly after initial Recall SC314 service was performed on June 15, 2026, and worsened prior to returning the car on XXX. Kia claims to have completed Recall SC314 on June 15, 2026. However, the recall work directly triggered immediate secondary failures in the high-voltage charging system. The dealership is now attempting to evade liability for recall-induced damage by labeling it 'wear and tear' and demanding $1,617 to fix a failure caused by their own recall service. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Source: NHTSA complaint ODI #11752715 · view all complaints for this vehicle at nhtsa.gov

After putting the car in park on a moderate slope, I exited the car and about 2 seconds later, as I was connecting the charger, the car rolled backward 4 feet before coming to a stop. I immediately confirmed that the car was in park. The parking brake was *not* on. (Or at least, I did not manually set it- I don't know if this car activates the brake automatically when in park.) The right front wheel was on ice. All other wheels on bare gravel. The temperature was 36 deg F. This is an EV, so it may have some sort of event recorder built in. If so, look at roughly 9:10 EST on 2/10/22. This is a short-term rental from Enterprise, so I'll set the parking brake manually for the remainder of the rental and report it to them on return. Contact them if you want to inspect it. The registration lists the owner as "EAN Holdings LLC"

Source: NHTSA complaint ODI #11451321 · view all complaints for this vehicle at nhtsa.gov

When installing a car seat in the center position of the back seat using the seat belt, we found that the latch for the lower seat belt came undone. (It is the latch for the fixed corner of the lap belt. This is the black latch with the small slot to release the belt that is to remain hooked except to fold the rear seat flat rather than the latch with the red button.) We unbuckled the other side of the seat belt, removed the car seat, and found that the latch itself was defective. When the buckle is placed into the latch it can be pulled free with little effort. Upon further inspection, we found that if you place the buckle into the latch, wiggle it from side to side, and then pull it will remain latched. However, if you push the buckle down into the latch again it will release and can be pulled free without using the slot to release it. We took our vehicle to our local dealership, and they determined that the latch was indeed defective and a new latch was ordered to replace it. The part is not yet in, so it is not fixed yet. We will ask the dealership to track where the part is once replaced if it needs to be inspected. If we had not noticed that the latch was defective, we would have installed a car seat in that position with the possibility of the latch coming loose during an accident. There was no known warning signals that alerted us to this problem other than our own inspection of the problem. We have a video recording available that shows the problem much better than the pictures, but the form will not allow us to upload it here. Feel free to reach out to us to get a copy of it.

Source: NHTSA complaint ODI #11457201 · view all complaints for this vehicle at nhtsa.gov

The car has chrome trim on the dashboard that can cause blinding reflections and which also reflects in the side windows making it hard to see the side mirrors. This is a design flaw (not strictly a failure or malfunction) and the vehicle is available for inspection. The risk is that it impedes the driver's vision and the ability to use the mirrors and sometimes to read the display. Impeding the driver's vision can result in a crash. This problem has been reported by many owners on various forums, but I have not had it corroborated.

Source: NHTSA complaint ODI #11482959 · view all complaints for this vehicle at nhtsa.gov

In re: Manufacturer Recall Number SC314, NHTSA Recall Number 24V358 The Kia dealership (Aloha Kia Leeward, Waipahu, Hawai‘i) is imposing an unreasonable delay for this safety recall. Dealer was contacted in mid-July to schedule recall service. Dealer said it had to order the part. After not hearing from the dealer for two weeks, dealer was contacted on August 2 and recall service was scheduled for August 27 (claiming that was the first available appt.) Dealer kept the vehicle for 5 hours that day, then said the service could not be performed. Dealer said it would contact me to reschedule. After leaving messages and not hearing back from dealer, I went in person on 9-4-24. Dealer could not schedule recall service until October 7. Because this is a recall for safety issues, this repeated delay is unacceptable. I wish to put this complaint in the record regarding the disregard for vehicle safety by Aloha Kia Leeward of Waipahu, Hawai‘i. Thank you.

Source: NHTSA complaint ODI #11612885 · view all complaints for this vehicle at nhtsa.gov