My 2020 Kia Sorento stalled and shut off while driving and eventually stopped working completely, requiring it to be towed to a Kia dealership. The dealership first replaced the starter and then the high-pressure fuel pump, but the vehicle still would not operate. After further diagnosis, I was informed that the timing chain had failed/broken and the engine needed to be replaced, with a new engine quoted at approximately $12,000. I am concerned that this type of sudden engine failure and shutdown could create a serious safety hazard, especially if it occurs while driving in traffic or at highway speeds. I am requesting that NHTSA document and review this incident for similar failures involving 2020 Kia Sorento vehicles.

Source: NHTSA complaint ODI #11757589 · view all complaints for this vehicle at nhtsa.gov

Driving on highway at 65, traction control light, airbag light, parking light, bcw warning, all came in at the same time. I was able to pull off to the side and re start engine to clear the lights. As soon as I got up to 40 lights one by one flickered on until up to highway speed and then all flickered and dash dings. Two independent shops ran diagnostics and noted that only battery was dead. Replaced battery and the lights came back immediately.

Source: NHTSA complaint ODI #11749809 · view all complaints for this vehicle at nhtsa.gov

The contact owns a 2020 Kia Sorento. The contact stated that while driving 30 MPH with her daughter and parents in the vehicle, an abnormal squeaking sound was heard emanating from the steering wheel. No warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed that the steering column needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but the repair was delayed because the manufacturer required information from the dealer, while the dealer claimed to be waiting for a response from the manufacturer. The failure mileage was 19,000.

Source: NHTSA complaint ODI #11749302 · view all complaints for this vehicle at nhtsa.gov

The contact owns a 2020 Kia Sorento. The contact stated that the front passenger’s side air bag warning light remained illuminated while an occupant was seated in the front passenger’s seat. The dealer was notified of the failure and informed the contact that there were no recalls or warranty associated with the vehicle failure. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 9,000.

Source: NHTSA complaint ODI #11761097 · view all complaints for this vehicle at nhtsa.gov

While driving my 2020 Kia Sorento on the freeway at highway speed, the panoramic sunroof suddenly shattered without warning. There was a very loud explosive sound that startled and frightened me while I was driving. I was not aware of anything striking the sunroof immediately before it shattered, and there were no warning lights, messages, noises, cracks, or other indications that the glass was about to fail. Because I was traveling at freeway speed when this occurred, the sudden explosion/shattering of the glass was extremely distracting and created a serious safety concern. I was frightened by the unexpected loud noise and could have lost control of the vehicle. Broken glass from a panoramic sunroof also presents a risk to the occupants of the vehicle and to other motorists. The component that failed was the panoramic sunroof glass. To my knowledge, the failure has not yet been reproduced or confirmed by a Kia dealer or independent repair facility, and the vehicle has not yet been inspected by Kia for the cause of the failure. I am reporting this incident because the sunroof appeared to shatter suddenly during normal highway driving without any prior warning, and I am concerned that this may represent a safety defect.

Source: NHTSA complaint ODI #11761230 · view all complaints for this vehicle at nhtsa.gov