When my car starts up, engine rpm is around 1500 or above 1000. If I would switch to reverse, the car sudden jerks back stronger and quicker than I expected even though my foot isn’t on the accelerator pedal and have pressed the brake lightly.

Source: NHTSA complaint ODI #11762062 · view all complaints for this vehicle at nhtsa.gov

My 2023 Mazda CX-5 (48,000 miles) is experiencing a loud mechanical whirring/grinding from the driver-side headlight assembly, a documented manufacturing defect involving foreign matter contamination of the internal LED cooling fan bearings (TSB 09-029/25). Despite the manufacturer acknowledging this factory-installed defect, Mazda has refused to proactively remedy the issue because the vehicle is nominally past its 36,000-mile bumper-to-bumper period. I have been explicitly advised by service personnel to continue operating the vehicle until the headlight unit 'entirely fails' before further assistance may be considered. This 'fail-first' directive is a reckless disregard for public safety; the internal cooling fan exists specifically to prevent the high-intensity LED from overheating. A failure of this fan leads directly to the sudden burnout of the main headlamp while the vehicle is in motion. Mazda is essentially requiring me to drive a vehicle with a known, ticking-clock lighting defect and wait for a total loss of visibility at night before they will address a part that was contaminated during their own production process. This is a critical safety hazard that places myself and other drivers at risk of a collision due to sudden headlamp failure.

Source: NHTSA complaint ODI #11730353 · view all complaints for this vehicle at nhtsa.gov

On 09/01/2026 at approximately 55 mph, I was driving with adaptive cruise control engaged. The vehicle ahead decelerated abruptly. My vehicle began braking hard with no input from me for a fraction of a second. A red BRAKE warning appeared in the instrument cluster with an audible alarm. I then applied the brake pedal hard. On first contact the pedal barely moved from its rest position and was extremely firm. About a second into my application, while still traveling at over 25 mph, pedal resistance dropped sharply and pedal travel increased substantially. I had to push the pedal several inches farther to get back to comparable deceleration. The pedal did not pulse or vibrate. I came to a matching speed roughly one car length from the vehicle ahead, and only because I kept braking hard. I did not see an MRCC Cancelled message, though the BRAKE warning occupies the same part of the display, so I cannot say whether the initial deceleration came from Mazda Radar Cruise Control or Smart Brake Support. No brake, ABS, or DSC warning lamp illuminated before, during, or after the event, and none has since. There were no symptoms beforehand, and the brakes have worked normally since. Failed component: unknown. I cannot determine whether the change in pedal feel came from the brake booster, the DSC hydraulic control unit, the master cylinder, or the driver assistance system handing brake control back to me. The vehicle has not been inspected by anyone and no service center has reproduced the issue. The vehicle is available for inspection if needed. If a driver assistance system is commanding brake pressure and withdraws it during the driver intervention, total deceleration can drop at the moment when the driver still wants to stop aggressively to avoid a crash. Suddenly, the driver has to find the extra pedal travel while still closing on the obstacle. I slowed to a safe speed in time. With less room, or less attentiveness, I may not have been able to.

Source: NHTSA complaint ODI #11761780 · view all complaints for this vehicle at nhtsa.gov

We purchased a certified pre-owned Mazda CX-5 from Wellesley Mazda in [XXX] on XXX. As soon as we got home and tried to exit the vehicle, we noticed that the driver's seatbelt was not releasing. Since then, we have noticed that the seat belt has not latched or unlatched properly. Our concern is that a manufacturer-certified vehicle was delivered to a consumer with an intermittently failing primary locking restraint mechanism. There should have been a 160-point inspection done before this car was delivered in order for it to be considered pre-owned. This car is driven by our son who has been put at risk by a faulty restraint device. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Source: NHTSA complaint ODI #11757773 · view all complaints for this vehicle at nhtsa.gov

The driver-side power door mirror on my 2023 Mazda CX-5 vibrates excessively at highway speeds above 75 mph, especially on windy days. The vibration is so severe that it causes a blurred and distorted view, making it difficult to clearly see vehicles in adjacent lanes. This poses a significant safety risk, as it impairs my ability to make safe lane changes and monitor surrounding traffic. I brought the issue to the attention of my Mazda dealership during a scheduled service appointment, but they dismissed it as "normal" and quoted approximately $700 to replace the mirror - despite the fact that this appears to be a known issue with Mazda vehicles. Numerous owners of recent Mazda models have reported similar problems online, yet Mazda has not issued a Technical Service Bulletin (TSB) for the 2023 CX-5. I am attaching a previous TSB (09-002/13) that Mazda released for earlier CX-5 models (2013–2014), which addressed the same mirror vibration issue through structural reinforcement and mirror replacement. This suggests the problem may still persist in newer models. The mirror is available for inspection upon request. No warning lights or messages were displayed, and the issue began shortly after I started driving the vehicle on highways. Link to previous TSB - [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Source: NHTSA complaint ODI #11684928 · view all complaints for this vehicle at nhtsa.gov

The air conditioning compressor clutch suddenly would not engage, leading to reduced visibility out of the windshield during humid weather in Oklahoma springtime and extended times for windshield to defog. Temperatures inside the vehicle also rose to very high levels without air conditioning available, even with windows down while driving. No crash or injuries but this presented an unsafe situation for a vehicle with only 39,000 miles and purchased new from the dealership. There were no indicator lights, messages, or warnings, other than observation that air conditioner vents were no longer blowing cold air when selecting the AC button after problem occurred. Problem was verified by both an independent mechanic and our Mazda dealership. AC system was overcharged from the factory per diagnostic results, leading to internal AC compressor short and early component failure.

Source: NHTSA complaint ODI #11733145 · view all complaints for this vehicle at nhtsa.gov