The contact owns a 2023 Mercedes-Benz Sprinter 3500. The contact stated that while driving 65 MPH, there was an abnormal metal grinding sound coming from the rear of the vehicle. While driving at various speeds, the vehicle went into LIMP Mode. The transmission was shifted into neutral(N) and the vehicle was restarted. The vehicle was taken to the dealer, who diagnosed the vehicle with pinion bearing failure and the LIMP Mode failure causing an Emissions issue. The rear axle, air charger GPS, turbo, and oil sensor were all replaced. The vehicle was taken to the dealer and was diagnosed with the same failure. The vehicle was repaired. The manufacturer was informed of the failure and a case was opened to discuss a buy-back offer for the failure. The failure mileage was approximately 9,600.

Source: NHTSA complaint ODI #11747880 · view all complaints for this vehicle at nhtsa.gov

I am filing a formal complaint against Lazydays RV (Tampa, FL) for repeat violations of NHTSA safety standards and probable violation of their 2022 Consent Agreement and Compliance Monitoring Order. In May 2024, I purchased a 2023 Mercedes-Benz Sprinter RV from Lazydays. The vehicle was sold as “new” and delivered to South Carolina. Upon delivery, I discovered it had been stripped of OEM parts and tampered with prior to shipment, including a non-OEM “Tampa Bay Battery” substituted for the factory-installed Mercedes-Benz battery. That non-compliant battery failed in May 2025, leaving us stranded and requiring an emergency replacement. Lazydays also failed to register the manufacturer’s warranty with MBUSA for nearly one year, preventing factory coverage during that time. I later obtained confirmation from the RV manufacturer (Thor Motor Coach) that the vehicle was missing several required OEM components (bike rack, ladder, seat and door covers), and they were forced to replace these at their own cost — not Lazydays’. The dealership also collected $1,600 in SC registration/title fees, then failed to perform the service or refund the charge. This case reflects a pattern of deceptive delivery, false documentation, and equipment tampering, all of which directly impact vehicle safety, warranty integrity, and federal compliance. Lazydays’ behavior is consistent with violations described in their 2022 NHTSA Consent Order. I am formally requesting NHTSA investigate this matter as a repeat offense under active probation and compliance oversight. Please initiate a formal compliance review of Lazydays RV under its existing NHTSA oversight. This is no longer a single instance — it is a persistent pattern of regulatory violations that impact consumer safety and vehicle compliance.

Source: NHTSA complaint ODI #11674564 · view all complaints for this vehicle at nhtsa.gov

I was driving my van and out of nowhere it locked up and power steering malfunctioned. I was in NY at the time. Tried to get MB to help explain what was happening. Said they would send a Tech out. Found out they were going to send a tow truck and that was it. I had several pups on board and had to get them safe. So I figured out how to drive it with no power steering all the way back to Houston. While driving we got into some rain. Which for whatever reason the rain kicked the power steering on for just 5 or less seconds. This kept happening on and off while in wet road conditions. I was freaked out as the change made the steering go from impossible to beyond sensitive. We could have so easily flipped had I not been paying attention and driving at a slow speed. This also made all the safety features not accessible. No blind spot, cruise control, lane change or any of the important functions this van is equipped with. I would like to note that MB had to replace the engine due to a defect. Took 4 plus months. I have had issues ever since. Engine light came on all 4 of my trips. I know one that was the reason is VOX sensor. Fixed it and then happened next trip. Plus other sensors replaced. This van has been horrible! Bought it and was told they run up to 500k and these new engines they expect to see a million miles. I can’t even get it to 100k I called MB USA and started a complaint. They acted concerned and would contact me within 48 hours. Never to hear back from anyone. This was the same response when the engine malfunctioned. I was going to be given a loaner van and never heard or could connect with anyone.

Source: NHTSA complaint ODI #11584991 · view all complaints for this vehicle at nhtsa.gov

There was an SRS Error message. The SRS system is non-functional on a vehicle with 400 miles. The dealership has attempted to fix the problem by replacing the fuse and control unit, but it appears to be a coding - programming issue. An engineering case has been opened for 2 weeks, but they have given me no notice of what or when the next step takes place.

Source: NHTSA complaint ODI #11733355 · view all complaints for this vehicle at nhtsa.gov

Vehicle hood opened on its own while driving. We have video of the incident from front dash camera. Vehicle hood was not operated prior to 300 miles when employee start the day with pre-trip information. There were few people also verified that the hood was closed properly. While driving from Ontario, CA to Las Vegas , NV and driver returning from Las Vegas the vehicle midway to Ontario California, the hood suddenly opened and smashed the windshield, driver was successfully able to pull over as he was driving in right lane blindly.

Source: NHTSA complaint ODI #11557883 · view all complaints for this vehicle at nhtsa.gov

I noticed there was a reall of the front hub assemblies, however my truck must not be on the list of vins affected. I’m not sure where the problem originated, but I just passed over 20k miles and im experiencing signs and symptoms of what that recall would affect, this started a few weeks ago, not getting any better. It just stars vibrating and shaking pretty violently. like a wheels coming off. My father is also experiencing similar issues in is 2022 king ranch with 40k miles. Both trucks, very low mileage shouldn’t show these sort of symptoms yet. I’m not sure if they go hand and hand but it also disengages advanced track and all the front sensors and what not when it happens. After reading a few articles I do not feel the truck is safe on the road until probably inspected.

Source: NHTSA complaint ODI #11611821 · view all complaints for this vehicle at nhtsa.gov