I bought this used truck with 60K miles on it in 2024. It is a 2020 truck. At 136K the engine failed.........with the infamous [XXX]. I have an excel summary spread sheet on all maintenance I had done since I owned this truck and I did not pull or haul anything. I heard a tick for about 10 days before I took it to my dealer whom I bought it from and they stated after "scoping" that the # 8 cylinder misfired and cylinder wall scored and the lifter pin bearing failed thus cam shaft damaged and exhaust manifold cracked. They had to replace the engine with a remanufactured engine from [XXX] and replaced intake and exhaust Manifold at a cost of $ 15,021 out of my pocket. I was stuck with no options logically. I do not have a problem with the Dealership - [XXX]. I have a problem with Ram Engineering, Stalantis design. To me there is no excuse to have a big cast iron block v-8 fail at 136K miles. There are many more ram owners who have this same problem I just stated that I had. If I knew then what I know now i would have never bought this truck with this 5.7L engine. There were no warnings, messages or anything displayed to alert there was a problem. I expect that there was not enough oil flow to # 8 cylinder ( which is all the way back to the left rear ( passenger side) of the engine ) looking from the front of the truck as I read many Ram forums on line. I changed to oil every 5K miles with Mobil 1 full synthetic oil along with the filter - either Mobil 1 or WIX filters. some of the best on the market. I do not know what I can do now but this is rediculous. I won't get burned again. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Source: NHTSA complaint ODI #11764777 · view all complaints for this vehicle at nhtsa.gov

Twice in the past two years, the eTorque system had failed will driving on the highest. When the unit fails, you lose all power asks if you're battery is low, you can pose the ability to even steer. The first time, I was on the i87 going north, and barely made it off the road. I was nearly hit by several semi trucks because this was on a blind turn with very little shoulder and I basically had to hide in the woods for safety. Just this past week, less than two years after the replacement, the same issue happened again. This incident was on route 11, which is very busy and I was unable to get my vehicle of the road. An officer came to shield me until the tow truck came, but it was very sketchy. This total cost is over 3000$, and no support from Ram as to why this is happening. This past time the bearings went and there was a lot of smoke coming from the engine area. The smell of burning electronics was choking in the cab; at that point I had to get out of the truck due to the toxic fumes. I did file a complaint with them. With this being such a safety concern, why is there no recall? I can't be the only person having had to deal with this. From what the dealership says, this is happening a lot and there is currently an 8 month wait for the part. Just thought you should be aware of this very serious issue.

Source: NHTSA complaint ODI #11757290 · view all complaints for this vehicle at nhtsa.gov

ABS light keeps coming on and off. The 4WD keeps going on and off and the cruise control and traction keeps working then not working. There is a recall for other year models for the ABS system that basically is exactly what’s happening with my truck. I am worried that it will go out and my truck will stop and cause and accident which almost happened today. This should be a recall alongside those other year models.

Source: NHTSA complaint ODI #11728834 · view all complaints for this vehicle at nhtsa.gov

While traveling at 40mph, total los of steering. Vehicle veered off the road and was uncontrollable. Power steering service light illuminated seconds before steering was inoperable. Turned off vehicle and restarted. Issue was not present after restart. Vehicle was recovered, sent to dealership for diagnostic. Problem could not be replicated at dealership. The next day, vehicle had the same issue. This time in a school zone. Vehicle is now parked and not driven out of fear.

Source: NHTSA complaint ODI #11764828 · view all complaints for this vehicle at nhtsa.gov

The contact owns a 2020 Ram 1500. The contact stated that while driving at an undisclosed speed, the air bag warning light unexpectedly illuminated. The vehicle was taken to the dealer, where it was diagnosed and it was determined that the air bag had failed and needed to be repaired. The vehicle was repaired; however, the failure recurred. The manufacturer was not made aware of the failure. The approximate failure mileage was 61,590

Source: NHTSA complaint ODI #11720936 · view all complaints for this vehicle at nhtsa.gov

The contact owns a 2020 Ram 1500. The contact stated that there was water leaking from the rear window of the vehicle. The contact referenced Technical Service Bulletin: 23-098-23, detailing a crack in the rear window near the third brake light that could allow water to enter the vehicle on the left and right sides. The contact confirmed that the vehicle had experienced leaks on both sides. The vehicle was taken to a dealer to be repaired under the TSB; however, the dealer declined to repair the vehicle. The contact stated that the vehicle met the mileage requirements, but the dealer stated that the vehicle was not included in the TSB. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 115,000.

Source: NHTSA complaint ODI #11752735 · view all complaints for this vehicle at nhtsa.gov

While driving on I 75 steam began coming through our vents while we were 50 miles from home. There was also a very strong smell of coolant, which gave everyone headaches and made them feel nauseous. After taking it to a shop. We found that it was the heater core that had began leaking. after doing some research, I found out that this is a common problem, even with vehicles of low mileage. I understand that mechanical failures happen however with a vehicle that only has 80,000 miles on it. This should not happen. I also believe this is a safety concern due to the fact that it causes the driver to become nauseous and possibly disoriented not to mention if enough coolant leaks, it can cause the vehicle to overheat or catch fire.

Source: NHTSA complaint ODI #11760389 · view all complaints for this vehicle at nhtsa.gov