One hour into traveling on the highway smoke began to come from under the hood so we pulled off to the side of the road. Upon opening the hood, after the smoke cleared, a fire was observed. At that point the passengers exited the vehicle and called 911. There was no warning lights or sounds indicating any problems prior to this. The car burned very quickly and the firefighters extinguished the fire but not before the entire car was burned to ashes. The car is wrapped and in the possession of the insurance company pending investigation.

Source: NHTSA complaint ODI #11674078 · view all complaints for this vehicle at nhtsa.gov

While driving there is a loss of power, the battery fails, electronic components shut down and car stops. Has happened intermittently. Replaced battery. This is a significant safety issue happened on freeway near exit ramp, in parking lot in driveway, everything cuts out. Opened hood and seems to be battery terminal connector. Recall was issued for certain Subaru models but not legacy. No warning, just cuts off. Is not a standard battery terminal connector. Had to secure battery down with cable ties.

Source: NHTSA complaint ODI #11745403 · view all complaints for this vehicle at nhtsa.gov

Since last October when a software update was performed on the vehicle I have had multiple(8-10) instances where the EyeSight system caused the emergency braking to activate when no other vehicles were nearby and a crash was not imminent. Usually it has been when entering a left hand gentle curve with a guardrail nearby, but it has also happened going straight ahead. The audible and visual alerts appear and hard braking occurs. The braking is severe enough that on rain or snow covered roads a crash might occur. The dealer inspected the vehicle and claims they found the calibration was off but the problem has occurred 3 more times since the calibration. I have contacted the dealer again but they have refused to acknowledge the problem further.

Source: NHTSA complaint ODI #11461729 · view all complaints for this vehicle at nhtsa.gov

At approximately 30k miles we had noticed the vehicle sounded loud, like a Turbo. It got worse and after returning from our vacation trip to Maine, it was noticeable louder but couldn’t place a finger on the problem. We brought the vehicle in to Victory Subaru in Morristown and they diagnosed the two rear failed wheel bearings. My question is how can both wheel bearings fail at only 20k and is there a potential for a system wide recall? Thanks

Source: NHTSA complaint ODI #11558437 · view all complaints for this vehicle at nhtsa.gov

The contact owns a 2020 Subaru Legacy. The contact received notification of NHTSA Campaign Number: 24V227000 (Air Bags); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Source: NHTSA complaint ODI #11616662 · view all complaints for this vehicle at nhtsa.gov

Driver's seat structurally unstable due to factory-installed welded nut shearing off the seat rail anchor at approximately 32,000 miles. Confirmed by Napleton Subaru technician on video. Physical component in owner's possession. Failure is consistent with prior Subaru seat rail weld recalls. This affects seat stability, occupant restraint geometry, and crash protection.

Source: NHTSA complaint ODI #11728577 · view all complaints for this vehicle at nhtsa.gov

The Thermo control valve is faulty and my friends is too. There is a class action lawsuit concerning this part. I replacement part was designed in 2021 and Subaru is aware of this issue, but refuses to do a recall. So far 2019, 2020 and 2021 models are affected.

Source: NHTSA complaint ODI #11578035 · view all complaints for this vehicle at nhtsa.gov