While driving on the highway, the vehicle suffered a sudden loss of engine power and went into a low-power/vapor lock state due to severe fuel starvation. This created a major safety hazard by stranding the vehicle on the highway shoulder and exposing occupants to high-speed traffic. Prior to the power loss, there were no advance warning lights until the engine stalled. A diagnostic scan performed immediately following the incident confirmed code P0087 (Fuel Rail/System Pressure - Too Low), along with cylinder misfire codes P030027 and P030100. To allow the vehicle to safely limp home from a remote location, an independent technician cleared the diagnostic trouble codes. An independent scan tool report clearly documented and confirmed the low fuel pressure fault prior to code clearance. The dealership subsequently declined to perform a warranty or recall fuel pump replacement citing the absence of active codes upon arrival, despite receiving the timestamped diagnostic report of the failure. The component has not been inspected by the manufacturer beyond the dealership's initial turn-away, but the vehicle and diagnostic documentation remain available for inspection upon request.

Source: NHTSA complaint ODI #11764071 · view all complaints for this vehicle at nhtsa.gov

The contact owned a 2020 Toyota Rav4. The contact stated that while pulling into a vertical spot and making a right turn, the vehicle suddenly accelerated, jumped the curb, the sidewalk, and continued driving down the sidewalk and crashed into a building. The brake pedal was depressed but was stuck. The vehicle failed to turn off, and the parking brake failed to engage. There were no warning lights illuminated. The air bags deployed as needed. A Police report was filed. The EMS workers were unable to depress the brake pedal. The undercarriage of the dashboard ripped the skin off both shins. The contact was transported to the trauma hospital, where medical attention was provided for four weeks to close the wounds. A skin graft was performed on both legs. The vehicle was towed to a tow lot. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The vehicle was deemed a total loss by the insurance company. The black box data was retrieved, which showed the acceleration, but no information if the brake pedal was depressed. The approximate failure mileage was 25,000.

Source: NHTSA complaint ODI #11750253 · view all complaints for this vehicle at nhtsa.gov

The contact owns a 2020 Toyota Rav4. The contact stated that while driving 20 MPH and making a turn, the vehicle felt like it was going to flip over. There was no warning light illuminated. The contact stated that the dealer was made aware of the failure, but the vehicle was not repaired. The manufacturer was made aware of the issue. The contact stated that the VIN was not included in NHTSA Campaign Number: 20V373000 (Steering). The contact associated the failure with the recall. The failure mileage was approximately 74,000.

Source: NHTSA complaint ODI #11744881 · view all complaints for this vehicle at nhtsa.gov

The contact owns a 2020 Toyota Rav4. The contact stated while driving 40 MPH, the message "Air Bag Fault" was displayed. An independent mechanic was contacted. The vehicle was taken to the independent mechanic to be diagnosed, and it was determined that the air bag needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and filed a case. The approximate failure mileage was 110,000.

Source: NHTSA complaint ODI #11730130 · view all complaints for this vehicle at nhtsa.gov

I ordered a plastic underbody cover (about 12×20 inches) through Toyota Arapahoe and paid $70 for the part. I was given an appointment for installation. When I arrived, I was told that the installation would take an hour and a half, even though the work consisted of fastening nine screws, while the old cover had been factory‑attached with only five simple self‑tapping fasteners, and this work was supposed to be free. After about an hour, I found my vehicle in the general parking lot, with no notification, no status update, and no explanation from the employees. When I asked why the work had not been completed, I was told: “There is not a single screw in the station,” “The screws may arrive in a week,” “The installation will cost about $100.” I asked the manager: “You want one hundred dollars just to fasten nine screws?” At that moment, the situation escalated. A man appeared who claimed to be “the boss of the entire station.” His behavior was aggressive and unprofessional. He refused to give his name or provide a business card. Because I speak English poorly, I asked him to say his name again. I tried to say “last name,” but due to stress I mistakenly said “famaly.” Instead of offering an electronic translator, this person began acting in a disturbing and irrational manner: shouting “family, family!”, rolling his eyes, moving around the room in an agitated way, and repeating the word loudly. I was confused and repeated the word after him, not understanding what was happening. Two other employees approached and began repeating “Go, go,” pressuring me to leave. Their behavior was clearly aimed at intimidation and forcing me out of the premises. After returning home, I measured my blood pressure: 170/90, which is significantly higher than my usual level of 140/80 and is considered a pre‑heart‑attack indicator. This dangerous spike in blood pressure was a direct result of the aggressive and humiliating treatment by the employees of Toyota Arapahoe.

Source: NHTSA complaint ODI #11751302 · view all complaints for this vehicle at nhtsa.gov