October 9, 2025 EPC light on. October 10, 2025, called Brown's VW in Charlottetown, PEI and brought the car in. The EPC light was off. The scan revealed that turbo on the vehicle had a seized wastegate. The cost of repair is $4,026.85 and a wait for parts. If the EPC light was flashing, the vehicle would buck and stop in the middle of the road causing a safety issue. There were no warnings previous to the EPC light going on. the vehicle is out of warranty but low mileage. Please note I spend 6 months a year in PEI, Canada and 6 months in the US. My address in Canada is: 81 Kilkenny Rd., Rte 250, Harrington, PE CIE 3A5. The vehicle is registered in PEI and had a RIV certificate. I was also told by an independent source that the above problem is common in the Atlantic Provinces because of the position of the wastegate and also the salt in the air in the Atlantic Provinces. I am certain in sea coast areas of the US, there is a similar problem with this VW turbo and the VW Tiguan is also affected. Many years of the VW Jetta have the same problem.

Source: NHTSA complaint ODI #11692696 · view all complaints for this vehicle at nhtsa.gov

On 2 separate occasions (in recent 2 months); the car would not restart and error messages would include printing the electrical parking brake engagement. Attempts to reset were futile. Car had to be towed. After 2nd incident, the VW dealership identified that the ground wire for the electrical harness that runs through fuse box and engine was severely overheated resulting in inability to start. There are no recalls on this item; from a safety standpoint, this could happen while driving and a loss of power could result with overheated ground wire condition. This is a potential very unsafe condition and a costly repair item. In comparison, the non-start stop button vehicles have experienced the same condition, and recalls were performed on 2018-2021 Jetta’s. The same exact case, severely overheated ground wires requiring complete replacement of main wiring harness.

Source: NHTSA complaint ODI #11763364 · view all complaints for this vehicle at nhtsa.gov

My brakes have always sounded weird to me. But the dealer and my mechanic assured me that they were fine. On Saturday 7/6/24, I noticed a horrible grinding noise. I took it to my mechanic and was told that due to a faulty brake caliper the passenger side front inner brake pad has gone metal to metal. I can see that there is a recall on the calipers for 2020 VW Jetta but it doesn't show up for my VIN #. I am having to pay $541.07 and feel that if this is a recall I shouldn't have to pay.

Source: NHTSA complaint ODI #11600522 · view all complaints for this vehicle at nhtsa.gov

The contact owns a 2020 Volkswagen Jetta. The contact received notification of NHTSA Campaign Number: 21V492000 (Air Bags) however, the part to do the recall repair was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and a case was opened. The contact had not experienced a failure. VIN tool confirms parts not available.

Source: NHTSA complaint ODI #11443210 · view all complaints for this vehicle at nhtsa.gov

While driving southbound on I-15 near Exit 300 (5300 S, Murray, Utah), the sunroof on my 2020 Volkswagen Jetta SEL suddenly and spontaneously exploded outward without any impact or external object striking the glass. The vehicle had approximately 72,000 miles at the time. There was no tint, film, or modification to the sunroof. The weather was clear, and the road was smooth. The explosion produced a loud gunshot-like sound, followed by glass fragments scattering across the sunshade. Fortunately, the sunshade was closed, which prevented most of the glass from falling into the cabin. However, the incident caused a significant distraction which posed a serious safety risk while driving at highway speeds. No warning lights, messages, or symptoms appeared before the failure. The glass appears to have shattered from internal stress rather than impact, as there were no visible signs of an object strike. The vehicle has not yet been inspected by Volkswagen, law enforcement, or insurance, but the glass remains available for inspection if needed.

Source: NHTSA complaint ODI #11698386 · view all complaints for this vehicle at nhtsa.gov