On [XXX] I was driving from Opelika, AL to Birmingham, AL. About 20 miles from home while driving on [XXX] in the left lane, my car would not accelerate. I pushe9 it down to the floor and there was no gas, so I had to get over to the right lane while rolling to get out of danger of the traffic and large trucks. MY car has been towed three time in about 3 month in 2025. I had it towed from my work parking lot twice because it would not crank. We bought new batteries, changed out the key batteries and this last incident. We had just got the car out of the shop for a fuel pump & fuel pump control module. (see receipt). I learned there was a Safety Recall from the NHTSA. However, when I called only to learn that my car had not been recalled. Therefore, I am quite confused because the safety issue recall no 09V343000 for 2010,S80 appears to be having the same issue. the software within the Central Electronic module (CEM) is not sending the signal to the fuel pump that was just replaced to the electronic module (PEM). The missing signal to the PEM inhibits the start of the fuel pump. This was a very frightening experience having a car stop on the highway while in the fast lane. Now the fear of it happening again is quite frightening, that's why I confused as to the seriousness of this electrical system software issue is not being taken for granted on my vehicle. If it was a problem for some, why would it not be a problem for all. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Source: NHTSA complaint ODI #11711169 · view all complaints for this vehicle at nhtsa.gov

Car would not crank, got fuel system replaced. Week later after being parked, while driving car cut off on highway. Mechanic has vehicle and has determined the issue is Central Electronic Module. Car is 2010 Volvo S80 with active recall but vin number is not apart of recall while experiencing same problem that almost caused a major accident. Vin [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Source: NHTSA complaint ODI #11711155 · view all complaints for this vehicle at nhtsa.gov

VOLVO BRAKE VACUUM PUMP IS LEAKING OIL ON THE 3.2 LITER MOTORS. VOLVO HAS FINALLY RECOGNIZED THE ISSUE WITH THIS LEAK AND HAS COME UP WITH A VOLVO BRAKE VACUUM PUMP REPAIR KIT (VOLVO 31401556 REPAIR KIT). ALONG WITH THE KNOW EXCESSIVE OIL CONSUMPTION OF THE 3.2 LITER MOTOR THIS COULD CAUSE LOSS OF BRAKE POWER. *TR

Source: NHTSA complaint ODI #10680411 · view all complaints for this vehicle at nhtsa.gov

I was driving down the road at 60mph, and my car started to wobble a little bit. I pulled over to see if something was obviously wrong and I didn't notice anything. At this point I thought that maybe I needed a new rear shock, but when I got back on the road, the wobble was so bad that I couldn't drive 25mph. I drove about 20mph until I could get to a safe place to pull over which was only about a mile. I took the wheel off and this was the moment that I noticed the tire had swelled up to the point that it wouldn't stand upright. It just fell over. I bought the tire (Riken Raptor) brand new 11 months ago. There is still a lot of tread on the tire. I had the presence of mind to pull over as soon as I noticed something wasn't right. I fear that if I had been on an interstate highway going 70mph, then something really bad may have happened.

Source: NHTSA complaint ODI #11526567 · view all complaints for this vehicle at nhtsa.gov

"SRS (SUPPLEMENTAL RESTRAINT SYSTEM) AIRBAG FAILURE URGENT" MESSAGE CAME ON. I TOOK VEHICLE TO THE DEALERSHIP FOR REPAIR. THE DIAGNOSIS WAS A FAULTY (R) FRONT PASSENGER SEAT BELT ASSEMBLY, WHICH WAS REPLACED. SEVERAL DAYS LATER THE FAULT MESSAGE RETURNED. DEALERSHIP CHECKED CODES AND INDICATED IT WAS THE SAME EXACT PART. I HAD THE PREVIOUS OWNER'S SERVICE HISTORY FOR THE CAR AND DISCOVERED THIS PROBLEM HAD OCCURRED 6 MONTHS PRIOR TO ME PURCHASING THE VEHICLE AND ANOTHER DEALERSHIP HAD ALREADY REPLACED THE SAME SEATBELT ASSEMBLY. SO INSTEAD, THE CURRENT DEALERSHIP REPLACED THE CONTROL MODULE FOR THE ENTIRE SRS SYSTEM. TWO DAYS LATER THE FAULT MESSAGE RETURNED AGAIN. THE CAR IS BACK AT THE DEALERSHIP FOR THE THIRD TIME NOW AND HAS BEEN THERE FOR A TOTAL OF ABOUT A MONTH. THEY ARE NOT SURE EXACTLY WHAT THE PROBLEM IS, BUT SUSPECT THE WIRING HARNESS UNDER THE FRONT PASSENGER FLOOR AREA. I HAVE RESEARCHED THIS ISSUE QUITE A BIT AND HAVE DISCOVERED A RECALL INVOLVING THE CONNECTION FOR THE CLOCK SPRING IN THE STEERING WHEEL FOR MY 2010, BUT MORE TELLING IS A RECALL AFFECTING 17,000 VEHICLES ENCOMPASSING MANY MODELS MY 2012 FOR A WIRING PROBLEM WHERE THE SEAT HARNESS MAY BECOME DISCONNECTED WHEN MOVING THE SEAT. PERHAPS EVEN THOUGH MY VEHICLE IS A 2010 IT STILL COULD BE THE SAME PROBLEM SINCE NOT MUCH HAS CHANGED BETWEEN THESE MODEL YEARS. I HAVE ALSO LEARNED THAT THE SRS SYSTEM DISABLES THE AIRBAGS WHEN THIS FAULT OCCURS SO THIS REPRESENTS A MAJOR SAFETY RISK TO ME AND MY FAMILY. *TR

Source: NHTSA complaint ODI #10514811 · view all complaints for this vehicle at nhtsa.gov

The contact owns a 2010 Volvo S80. The contact stated that there was condensation inside the vehicle. Additionally, the contact's daughter informed the contact that there was mold on the front passenger's side seat belt. The contact stated that there was mold on the lower seal near the front passenger's side door jam. The vehicle was taken to the dealer, where it was inspected. The dealer informed the contact that the upper part of the windshield was detaching on the passenger's and driver's sides. The contact stated that after the dealer removed the carpet on the passenger's side, the contact noticed water inside the vehicle and the wiring was wet. The dealer determined that the windshield needed to be replaced. The dealer advised the contact to file an insurance claim for the windshield replacement and another claim for the water damages. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 89,500.

Source: NHTSA complaint ODI #11665865 · view all complaints for this vehicle at nhtsa.gov