I was driving this car on Highway 99 on 7/11/2025. The dashboard flashed the message " Stop safely The vehicle will stop Propulsion system failure." I cut the lane and stopped my car on the Highway 99 shoulder. Just right, my car stopped on the Highway shoulder; it disabled itself and couldn't move at all. The gear shift can't shift to neutral (N). From the first message appearing on the dashboard to the car being disabled takes just a couple of seconds. When it happened, it was about 6:30 pm, rush hour. If I had not had a chance to drive the car immediately to the highway shoulder, the vehicle would have stopped in the lane, and I would have been crashed into by the cars behind me. This could lead to a catastrophic traffic accident. I want to mention that when the message appears on the dashboard, there is no sound alert. When people drive on the highway, their eyes are most likely focused on the road. Without a sound alert, people may not be aware of the message present. I contacted to the manufacturer on the 7/13, Sunday, they said they will open the case to investigation. As I report this incident, I have not heard from them yet. I uploaded the message photo that appears on the dashboard when the incident happened. Let me know if you need any information from me. Thank you!

Source: NHTSA complaint ODI #11673958 · view all complaints for this vehicle at nhtsa.gov

Rear collision warning system activated without reason. While stopped at a traffic light the RCWS activated and the emergency brake system engaged. This has been reported before to NHTSA. Vehicle was at the dealership for repairs or to identify the issue. Had to have it towed and dragged onto the flat bed tow truck as the cars emergency brake system was engaged and couldn't be disengaged. Received vehicle back and was told to bring it back once it happened again, which it has twice. But this time, emergency brake did not get stuck and have to be towed. It occurs without a vehicle or anything behind the vehicle and the vehicle was not in reverse when the system activated. I have contacted the Volvo consumer affairs to see if they could assist with resolving the issues as the vehicle remains in an unsafe driving state. They explained to me that it was up to the dealership/shop to locate the problem and they couldn't do anything to help. Which the dealership only suggested a replacement of the hydraulic brake system and I was advised that it might not fix the problem. I've since then been instructed to bring the vehicle back again for them to continue their road testing of the vehicle. The first time the vehicle was left for road testing it was only driven under a mile as per the recorded data showed through the Volvo car application with GPS and mileage tracking. This was explained to the service manager who reiterated to the service technician manager to road test the vehicle again. It was only driven approximately 30 miles with no issues identified by the technicians. I am currently waiting to bring the car back to the dealership for further troubleshooting / road tests.

Source: NHTSA complaint ODI #11560494 · view all complaints for this vehicle at nhtsa.gov

When using the power liftgate, in normal day to day use, the strut had seized and the lift gate was stuck open. As we were parked, we attempted multiple times and different ways to lower the lift gate by the buttons provided for their lift gate, the key fob and by manually attempting to close. The lift gate would not close nor latch and it appeared to be misaligned. When we called Volvo Santa Ana Ca, Mina, a representative who assisted, advised to hold the center button to reset the electricals. That did not work. He then advised to manually push the lift gate closed in order to drive it to them and be serviced. When advised by Mina, a Volvo associate, the liftgate still would not close and we were only able to close it half way before taking it to them to be examined and serviced as it is still under warranty. This became a HUGE health and safety issue when using a component of the car that is expected to function flawlessly day in and day out. If this had happened in our garage, we would not be able to get out. After a few attempts we drove the car to Volvo Santa Ana Ca, and dropped it off, they took several days to respond to let us know what was happening. The service department director, Mark, had advised that the strut seizure causing the lift gate to not function is a common occurrence and that the struts would be covered by the warranty but the liftgate WOULD NOT BE; as it was no longer aligning (due to faulty, defective strut) and thus Mark claimed it was on us, to replace or repair. This was absolutely ridiculous. The defective part of the Volvo is what caused the issue. If one is covered then both should be. We did not get into an accident. We were parked. There is absolutely no damage to the liftgate prior to this date. We then opened a case with Volvo customer service and they also denied it. We feel this is unethical and a health and safety issue that Volvo does not care about nor care to inform their customer that faulty struts are common.

Source: NHTSA complaint ODI #11594175 · view all complaints for this vehicle at nhtsa.gov