The contact owns a 2011 FORD Expedition. The contact stated that while driving, there was a burning odor coming from the vehicle. The contact stated at the time she did not see any smoke coming from her vehicle, so she assumed it was the outside. The contact stated that once she parked her vehicle, she sat inside the vehicle for approximately one hour before she exited the vehicle. The contact stated that when she came back to her vehicle, it was filled with smoke. The contact stated that the wires from the rear, middle row, passengers seat, on the driver's side of the vehicle had been burning. The contact stated that it did not cause a fire, however, it did melt the foam inside the seat. The contact stated the wires inside the seat were also melted. The dealer nor the manufacturer were notified of the failure. The failure mileage was 177,000

Source: NHTSA complaint ODI #11453503 · view all complaints for this vehicle at nhtsa.gov

JUN OF 2016 BRAKES STARTED GOING ALL THE WAY TO THE FLOOR WHILE BACKING OUT OF THE GARAGE WHEN ENGINE WAS FIRST STARTED. VEHICLE WOULD ROLL DOWN DRIVEWAY AND BRAKES WOULD NOT STOP IT UNTIL PUMPED. TOOK VEHICLE TO FORD AND THEY COULD NOT DUPLICATE. THEY FINALLY REPLACED THE MASTER CYLINDER AND THE PROBLEM STOPPED FOR 10 MONTHS. NOW THE PROBLEM IS BACK AND THEY CANNOT DUPLICATE AGAIN. HAS HAPPENED TWICE THIS TIME BACKING OUT OF GARAGE (LESS THAN 5 MPH). CAR HAS HAD A FULL BRAKE JOB, NO LEAKS, AND HAS 74K MILES.

Source: NHTSA complaint ODI #10985069 · view all complaints for this vehicle at nhtsa.gov

While getting tires replaced (Discount Tire), the representative pointed out that the aluminum-shelled lug nuts had swollen and become so deformed that the correctly sized socket could not be used. FUrthermore they could not be accurately torqued. The lug nuts had to be replaced, which cost $175.

Source: NHTSA complaint ODI #11459499 · view all complaints for this vehicle at nhtsa.gov

VEHICLE NEVER BEFORE IN COLLISION. FRONT BUMPER FULLY CONTACTED WITH SMALLER SUV, SUSTAINING SIGNIFICANT FRONT-END DAMAGE. ONLY PASSENGER FRONT AIRBAG DEPLOYED, DESPITE THERE BEING NO PASSENGER IN SEAT (POCKETBOOK WEIGHING ONLY FEW POUNDS ON THE SEAT, CERTAINLY NOT ENOUGH TO TRIGGER OCCUPANCY SENSORS). MY QUESTION IS TWO-FOLD: WHY DID AIRBAG DEPLOY IN EMPTY PASSENGER SEAT? AND MORE IMPORTANTLY, WHY DID IT NOT DEPLOY IN OCCUPIED DRIVER SEAT? IS THERE EVER A NON-OFFSET FRONT-END COLLISION WHERE FORCE OF IMPACT REQUIRES ONLY ONE OF TWO AIRBAGS TO DEPLOY? *TR

Source: NHTSA complaint ODI #10436690 · view all complaints for this vehicle at nhtsa.gov

The contact owns a 2011 Ford Expedition. The contact stated that the locking assembly on the driver’s side door was frozen and failed to operate as designed. Due to the issue, the contact was unable to enter the vehicle without using a hair dryer to warm up the lock. However, once the door was opened, the door was unable to close until the lock was heated up again. No warning lights illuminated. The vehicle was not taken to the dealer and was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline. The approximate failure mileage was 115,000.

Source: NHTSA complaint ODI #11566568 · view all complaints for this vehicle at nhtsa.gov

Odometer Fraud. The contact purchased a 2011 Ford Expedition. It was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 136,000, and at the time of registration, it was discovered that the mileage was 336,000. The contact called the seller, who advised that the sale was final and to end communications. An Attorney General and private attorney were contacted.

Source: NHTSA complaint ODI #11743503 · view all complaints for this vehicle at nhtsa.gov