Warning Message CHECK HYBRID SYSTEM, First incident driving on the road car gave warning message 10 mins later car went in limp mode in the middle of road and did not allow me too move (took to dealership they had the car for four days ,they reported no codes was found )2. Second Incident driving on highway and car gave warning message shortly after warning sign car start to not let me accelerate and was going very slow on highway, manage to pull over and engine light and message came up diagnostic fault code.

Source: NHTSA complaint ODI #11762668 · view all complaints for this vehicle at nhtsa.gov

multiple active faults, 12 active DTC codes, which have disabled the ABS, ESC and airbag communication lines, the dealer we took the car to refused to perform a full diagnostic and repair. I have been in contact with Kia corporate and they have consistently said that cannot make a dealer perform service. The dealer where we purchased the vehicle cannot see us until October.

Source: NHTSA complaint ODI #11762737 · view all complaints for this vehicle at nhtsa.gov

On March 13, 2026, Friday, at about 3:00 pm, was driving XXX on US XXX toward the XXX stop and go traffic backup for several miles. Sun was behind direction of traffic flow. Temperature was low-mid 50s and road was dry and no rain or snow. Winds were 10-15 mph with gusts to 25 mph. Road was 3 lanes in the east direction with one lane closed. Attempting to keep about a 3 foot distance from car in front. My was is a Kia 2025 Sorento PHEV model purchased in July 2024 and has had regular servicing. I was keeping a firm pressure on brake pedal to not allow car to roll into the car in front. Suddenly, the car surged forward into the other car. Keep both feet on the brake pedal to attempt to stop the car. Hit the other car and pushed it forward a foot or 2. The advertized FCA feature of the car appeared to have failed. It has stopped me in one prior situation. Damage to my Sorento is still be to determined. The car in front appears to have a body panel crease in the back tailgate. The damage appears to be at knee height. The car will be check out by KIA servicing this week (March 23rd, 2026). The car has several other quirks, but this is the most scary. Mileage is 9800. Most of my driving is main roadways city streets, US and Interstates. No recalls seem to address this situation. However, may other quirks are also not addressed. Report was filled with Maryland State Police.

Source: NHTSA complaint ODI #11726151 · view all complaints for this vehicle at nhtsa.gov

On [XXX], at approximately [XXX], I attempted to replace a flat tire on my 2025 Kia Sorento while the vehicle was parked on a flat, firm paved surface. I used the factory-supplied emergency scissor jack, rated at 1,200 kg or 2,645.5 lbs. and placed it at the designated factory pinch-weld jacking point. The plugin hybrid Kia Sorrento has a curb weight of over 4000 lbs which is more than the rated weight of the Kia supplied car jack. This is extremely irresponsible and dangerous. While raising the vehicle only enough to remove and replace the tire, the jack’s structural frame buckled, bent, and popped out from under the vehicle causing the vehicle suddenly fall back to the ground. While no one was hurt in the incident someone could have been injured or killed by the falling vehicle or by the car jack which popped out from under the car as it was crushed. In this instance, no one was underneath the vehicle, and no injury occurred although it would have been very easy for this to have resulted in serious injury or death if the jack failure occurred while the tire was removed or a tire iron engaged during the failure. I feel fortunate to not have been seriously injured. There was no visible deformations or other symptoms before the failure. The problem was not reproduced because the jack sustained permanent structural damage and could not safely be used again. The vehicle and failed jack were inspected by Serramonte Kia, 600 Serramonte Boulevard, Colma, CA 94014, on [XXX], at approximately [XXX]. The failed jack has been retained and is available for inspection upon request. Photographs and dealership documentation are also available. Because Kia supplied this jack specifically for emergency tire changes on this vehicle, and it failed during its intended use under proper conditions, I request investigation into whether the jack has inadequate structural strength or design margin, defective materials or manufacturing, or another safety defect INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Source: NHTSA complaint ODI #11752370 · view all complaints for this vehicle at nhtsa.gov