⸻ My 2022 Nissan Pathfinder experienced a catastrophic engine failure at approximately 70,000 miles. The vehicle suddenly developed severe engine knocking and required a complete engine replacement. There were no engine warning lights or oil pressure warning lights prior to the failure. The vehicle had been maintained according to the manufacturer’s recommended service intervals, including oil changes using full synthetic oil. The Nissan maintenance system indicates oil changes at approximately 10,000 mile intervals. Because there were no warning indicators prior to the failure, the issue occurred without any notice to the driver. A sudden engine failure without warning could present a potential safety risk if it occurred while driving in traffic or at highway speeds. The repair required a full engine replacement at a cost exceeding 8,000. The vehicle was just slightly outside the manufacturer’s powertrain warranty at the time of failure. Given the relatively low mileage and lack of warning indicators before the engine failure, I am submitting this complaint so the issue can be documented and evaluated for potential safety concerns or patterns of engine failure in this vehicle model.

Source: NHTSA complaint ODI #11724324 · view all complaints for this vehicle at nhtsa.gov

First Incident- volume kept rising on its own. Would turn it down, it would go right back up. Would turn the radio off, it would turn on by itself and would keep rising until full blast. Vehicle was parked, came back from work, turned vehicle on and the volume was fine on it. Second Incident- (this has happened twice) about a month after the volume incident. This time the vehicle would accelerate by itself. No cruise control was on, vehicle would keep going faster and faster. First time this happened the vehicle needed to be towed, cops were involved. I finally was able to stop the vehicle at a red light (where it eventually broke down and would not start). Extended warranty covered the tow. There was no check engine light on. Replaced the battery as I was told the errors were pointing back to low voltage. After battery was replaced, maybe three weeks later the vehicle did the same thing on the highway again. Car speed kept increasing on its own, no cruise control or pedal input. Vehicle kept speeding. I took this vehicle to Moon Township, PA Nissan Cochran dealership and they could not replicate the issue. I have video proof the first time this happened where the vehicle kept increasing in speed without pedal input. I have two kids under the age of [XXX] , This is an unsafe vehicle and it has lost my trust completely. The extended warranty company for this vehicle said they can’t do anything since the dealership says no check engine light is on. Third incident- got into vehicle, turned the vehicle on and the parking brake would not release. The parking brake was never applied in the first place so I have no clue how or why it was on when I turned the vehicle on. I just recently called the dealership on this issue now (Moon Township, Nissan Cochran) and will see what they say. Again, no check engine light is present. I am at a loss on this vehicle. 2022 with only 45k miles on it and have never experienced this many issues with a vehicle before! It is unsafe. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Source: NHTSA complaint ODI #11733786 · view all complaints for this vehicle at nhtsa.gov

The contact owns a 2022 Nissan Pathfinder. The contact stated that the vehicle previously received a repair on the rear brakes at approximately 30,000 miles; however, the vehicle recently received an oil change at an independent mechanic, and it was discovered that the rear brakes showed excessive wear. Additionally, it was discovered that the rear shocks were worn. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 46,000.

Source: NHTSA complaint ODI #11761087 · view all complaints for this vehicle at nhtsa.gov

For the past couple of months we noticed the car is swaying to one side when it accelerates. We took the car for an alignment and the problem persists. The car is now swaying aggressively to one side when driving at higher speeds. This occurs while driving in the highways. We have to be extra cautious because it can hit another car driving in the next lane. We took the car to the Weston AutoNation dealer repairs and they informed the car needs to repair tie rods and control arms. The car has never been in an accident. The car has less than 35,000 miles.

Source: NHTSA complaint ODI #11688009 · view all complaints for this vehicle at nhtsa.gov

I am submitting this complaint to report a serious safety issue involving the airbag system in my vehicle. The airbag warning light has illuminated on the dashboard, and I also received a notification indicating that the airbag system may not function properly in the event of a crash. This creates a significant safety risk, as the airbags may fail to deploy when needed. I contacted an authorized Nissan dealership regarding this issue. The dealership informed me that they have received similar complaints from multiple vehicles of the same generation as mine. However, they advised me to wait for a potential recall rather than proceed with immediate diagnostic and repair, stating that repairs at this time would be very expensive despite the vehicle being only three years old. Given the critical safety function of airbags, this situation is extremely concerning. A potential failure of the airbag system could result in serious injury or death in the event of an accident. I am requesting that this issue be investigated promptly to determine whether a defect exists that warrants a safety recall. It appears this may be a broader issue affecting multiple vehicles, not an isolated incident

Source: NHTSA complaint ODI #11725558 · view all complaints for this vehicle at nhtsa.gov

Components Affected: STRUCTURE:SUNROOF | ELECTRICAL SYSTEM | VISIBILITY/WIPER Description of Safety Hazard: My 2022 Nissan Pathfinder suffers from a severe, chronic manufacturing defect causing substantial water intrusion into the vehicle's cabin through the sunroof assembly during rainfall. To date, the manufacturer’s authorized dealership network has attempted to repair this exact leak three separate times and has failed to cure the defect. This unfixable water leak creates two distinct, critical safety hazards: 1. Electrical Failure/Fire Risk: Water actively flows into the headliner, pooling behind the dashboard and running down the A-pillars. This directly exposes critical safety electronics—including the side-curtain airbags, rearview mirror sensors, forward-collision camera arrays, and steering column electrical modules—to active moisture. This creates a severe risk of sudden, catastrophic electrical short-circuits, unintended airbag deployment, or sudden loss of safety assist systems while operating the vehicle at highway speeds. The vehicle is currently leaking for a fourth time. Because the manufacturer's certified network is entirely incapable of sealing the vehicle or curing this defect, the vehicle remains an ongoing safety hazard to its occupants and other motorists on the road.

Source: NHTSA complaint ODI #11744421 · view all complaints for this vehicle at nhtsa.gov