Ask the seller for proof the repair was completed, or run the free VIN check. Recall repairs are done at no cost by a dealer.
Recalls
Safety issues the manufacturer must repair for free. A recall means confirm the fix was done, not walk away.
Safety recall
A seat back that fails to lock may not properly restrain an occupant during a crash, increasing the risk of injury.
- Remedy
- Dealers will replace the return springs in the seat back recliner assemblies, free of charge. Owner letters were mailed September 9, 2026. This is a phased recall. Owners may contact Toyota’s customer service at 1-800-331-4331. Toyota's numbers for this recall are 26TB06 and 26TA06.
- Status
- Remedy available. Confirm by VIN that this repair was completed.
- What to do
- Enter the VIN on NHTSA's recall lookup to confirm this car was repaired.
Seat belts recall
A seat belt that does not properly restrain an occupant increases the risk of injury during a crash.
- Remedy
- Dealers will reinstall the seat belt anchor with a new bolt, free of charge. Owner notification letters were mailed January 27, 2026. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 25TA16.
- Status
- Remedy available. Confirm by VIN that this repair was completed.
- What to do
- Enter the VIN on NHTSA's recall lookup to confirm this car was repaired.
Safety recall
A rearview camera that fails to display an image can reduce the driver's view behind the vehicle, increasing the risk of a crash.
- Remedy
- Dealers will update the parking assist software, free of charge. Owner letters were mailed January 2, 2026. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB13 and 25LB06. Subaru's number for this recall is WRE25.
- Status
- Remedy available. Confirm by VIN that this repair was completed.
- What to do
- Enter the VIN on NHTSA's recall lookup to confirm this car was repaired.
Electrical system recall
An instrument panel display that does not show critical information can increase the risk of a crash or injury.
- Remedy
- Dealers will update the instrument panel software over-the-air (OTA) for non-PHEV vehicles, free of charge. For PHEV vehicles, dealers will inspect the instrument panel assembly, and either replace it, or update the software, free of charge. Owner letters were mailed December 5, 2025. Additional letters will be sent, anticipated in May 2026. This is a phased recall. Owners may contact Toyota's customer service at 1-800-331-4331. Toyota's numbers for this recall are 25TB08 and 25TA08. Lexus' numbers for this recall are 25LB05 and 25LA05.
- Status
- Remedy available. Confirm by VIN that this repair was completed.
- What to do
- Enter the VIN on NHTSA's recall lookup to confirm this car was repaired.
Safety recall
A vehicle with an incorrect maximum capacity weight value may be overloaded, which can increase the risk of a crash.
- Remedy
- GST will mail new labels to owners, free of charge. Owner notification letters were mailed September 16, 2024. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 24R2.
- Status
- Remedy available. Confirm by VIN that this repair was completed.
- What to do
- Enter the VIN on NHTSA's recall lookup to confirm this car was repaired.
Tires recall
Tires with an insufficient load rating can be overloaded and fail, increasing the risk of a crash.
- Remedy
- SET will inspect and replace the tires and information placard, as necessary free of charge. Owner notification letters were mailed August 16, 2024. Owners may contact SET's customer service at 1-866-405-4226. SET's number for this recall is SET24A.
- Status
- Remedy available. Confirm by VIN that this repair was completed.
- What to do
- Enter the VIN on NHTSA's recall lookup to confirm this car was repaired.
Tires recall
Tires with an insufficient load rating may be overloaded and fail, increasing the risk of a crash.
- Remedy
- GST will inspect and replace the tires as necessary, and install a new tire information label as necessary, free of charge. Owner notification letters were mailed August 8, 2024. Owners may contact GST customer service at 1-800-444-1074. GST's number for this recall is 24R1.
- Status
- Remedy available. Confirm by VIN that this repair was completed.
- What to do
- Enter the VIN on NHTSA's recall lookup to confirm this car was repaired.
Owner complaints by system
Unverified reports owners filed with NHTSA, grouped by the part of the car. Useful for spotting patterns. Open a group to read recent examples.
Engine & powertrain
14
Most reports here involve fluid leaks. Of these, 2 mention a crash, 1 mention an injury.
Read full complaint
I have been experiencing a gas smell issue with my Toyota Highlander near the rear of the car by gas cap area upon putting in gas and driving. The smell starts typically when it’s a hot day outside and I only usually get half a tank worth of gas. After getting gas and driving about 15-30 mins. Is when the smell of gas starts. I recently took my car it to the local Toyota dealership and they checked the purge valve, fuel canister and EVAP system. The technician did state that the fuel rail failed slightly. But overall, they stated there no codes after testing and the technician did state he smelled the gas faintly. But that since there are no codes to pinpoint an issue they cannot fix or figure out the issue. Please figure out this issue, as this is a real concern to have this issue and drive this car with myself and family in it.
Source: NHTSA complaint ODI #11761388 · view all complaints for this vehicle at nhtsa.gov
Electrical & infotainment
5
Most reports here involve software faults.
Source: NHTSA complaint ODI #11723811 · view all complaints for this vehicle at nhtsa.gov
Brakes
9
Most reports here involve loss of braking. Of these, 2 mention a crash, 2 mention an injury.
Read full complaint
BRAKING SYSTEM WHEN APPLYING BRAKES, ESPECIALLY WHEN APPLYING DOWNHILL, TEMPORARILY RELEASES AND ACTS AS THOUGH BRAKES ARE NOT APPLIED ANY LONGER FOR A BRIEF PERIOD OF A FEW SECONDS THEN REAPPLIES. IT DOES SO THAT IT IS VERY OBVIOUS WITHIN THE CAR. THERE IS A KNOWN ISSUE WITH THE TOYOTA HIGHLANDER HYBRID BRAKING SYSTEM AND IT SEEMS THAT IT HAS NOT BEEN RESOLVED IN NEWER MODELS. ASKING NTHSA TO ADDRESS WITH TOYOTA AND GET IT FIXED.Technical Service Bulletin for 2020-2022 Toyota Highlander Hybrid Braking Issue. Some drivers reported a momentary transition from regenerative braking to hydraulic braking, particularly when driving downhill or turning with light brake pedal application. Toyota has provided a software update for the brake actuator control module to improve brake feel.
Source: NHTSA complaint ODI #11733520 · view all complaints for this vehicle at nhtsa.gov
Steering, suspension & tires
2
Most reports here involve premature wear.
Read full complaint
The tires have not “failed,” but they are dry rotting on both the sidewalls and inside the tread. These came as the OE tires, size is 235/65 R18. This is a daily driven car with almost 30,000 miles on the odometer. There is no reason the tires should be dry rotting. This is a severe safety hazard, as most tire shops wouldn’t mount, balance, or even touch these tires if they were dry rotted this quickly. The tires have been rotated every 10,000 miles or so, and have been kept properly inflated throughout their life. They were made on the 42nd week of 2023. They began showing symptoms of light dry rotting around 6 months ago, but the problem has finally spread to the sidewall.
Source: NHTSA complaint ODI #11719690 · view all complaints for this vehicle at nhtsa.gov
Airbags & seat belts
2
Most reports here involve fluid leaks.
Read full complaint
The third row seat belts in the 2024 Highlander are very difficult to latch. I had to bring my Highlander to the dealership twice over the seatbelt buckles in the third row. The buckle part does not lift up high enough to grab the buckle to latch it. Anytime a child old enough to be in the third row sits back there an adult has to Buckle them because they can’t get the seat belt to latch to the buckle. It’s supposed to be a family friendly vehicle but if a 7 year old can’t buckle themselves, that is an extremely unsafe design. It often takes me 10-15 minutes to get kids buckled in my third row because of how challenging it is to get the seat belts to latch as an adult. I have had to use a butter knife to get them to latch. This safety issue , I did not have in my 2021Highlander. I don’t feel children are safe in the third row of my vehicle. This time the dealership said it had a debris in the buckle and that’s why it wouldn’t latch. However even when they do all latch they are very difficult to latch. These should be replaced with safe buckles that latch the first attempts
Source: NHTSA complaint ODI #11745432 · view all complaints for this vehicle at nhtsa.gov
Structure & body
6
Most reports here involve other issues. Of these, 1 mention an injury.
Source: NHTSA complaint ODI #11742837 · view all complaints for this vehicle at nhtsa.gov
Other systems
4
Most reports here involve other issues. Of these, 1 mention an injury.
Read full complaint
I've been waiting for a recall repair based on a recall file nearly 8 months ago now. This recall still appears to have no remedy. I continue to get emails about this issue from my dealer, but when I call to schedule the appointment to fix it, they continue to tell me that no remedy is available yet.
Source: NHTSA complaint ODI #11735646 · view all complaints for this vehicle at nhtsa.gov
How does it compare with other years? The 2024 has 42 complaints on file, fewer than the 2023 (180). Of the 15 model years of the Toyota Highlander we cover, the 2021 has the most (512). Older model years have had longer to collect complaints.