The vehicle experienced a sudden, severe loss of vehicle control while driving twice. Without any warning lights, dash indicators, or stored error codes, it began violently surging and decelerating uncontrollably around 20 mph with severe bucking. My [XXX] daughter was driving. Fortunately, this occurred on a quiet local residential road at 5 am; had this sudden failure occurred at highway speeds, it would have resulted in a catastrophic rear-end collision. The vehicle was purchased in May 2023, has 42k miles, and was used normally for school commuting. Incident 1 (XXX): Towed to Toyota. Techs could not diagnose it and opened a Tech Case. Per instructions, dealer replaced shifter assembly due to internal short (Part 33560-0R070). However, within 24 hours of return, the exact same dangerous failure reoccurred suddenly without warning in mild traffic. Experiencing an uncontrollable vehicle was terrifying. Fortunately no crash occurred, but it was towed back immediately. When I raised urgent safety concerns and sought a permanent resolution, Toyota stated it takes 60 days for review. During this period, if the dealer requests loaner return, I must return it immediately. They further stated that as soon as the dealer declares the vehicle "ready for pickup," I must retrieve it immediately or be charged daily storage fees. When I asked how the dealer could diagnose and repair the car entirely on their own—without Toyota Corporate engineering instructions while Toyota is supposedly still investigating the root cause—Toyota had no logical answer. When I asked who assumes legal and safety responsibility if another failure or accident occurs after pickup, Toyota Executive Offices explicitly stated "no one" assumes responsibility. No reasonable consumer would drive an unresolved, life-threatening defect under an explicit disclaimer of safety accountability. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Source: NHTSA complaint ODI #11760840 · view all complaints for this vehicle at nhtsa.gov

While making a left turn in my 2026 Toyota RAV4, the vehicle's Automatic Emergency Braking / Pre-Collision System suddenly activated without cause. The system sounded an audible warning beep and forced the vehicle to brake and come to a hard stop mid-turn. There was nothing in front of me that should have triggered the system. This put my safety and the safety of other drivers at risk. The forced stop occurred suddenly and unexpectedly while turning, which nearly caused an accident, as vehicles behind me had no warning that I would suddenly brake mid-turn. There were no warning lamps or dashboard messages prior to the incident — the false activation occurred suddenly with no prior symptoms. I have dashcam footage of the incident attached below.

Source: NHTSA complaint ODI #11754058 · view all complaints for this vehicle at nhtsa.gov

The contact owns a 2023 Toyota Rav4 equipped with Firestone Tires, Tire Line: Destination LE2, Tire Size: 225/65/R17, DOT Number: [XXX]. The contact stated that while driving on [XXX], the red light illuminated and there was an abnormal rumbling sound. The contact pulled over at the exit and became aware that the outside circumference of the tire was shredded on the driver’s side rear tire. The tread was in good working order. The vehicle was taken to the local dealer, where all four tires were replaced. The manufacturer was contacted and informed the contact about rebates on the tires. The tire and failure mileage was approximately 58,000. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Source: NHTSA complaint ODI #11761355 · view all complaints for this vehicle at nhtsa.gov

I am reporting a serious safety concern involving the rear passenger-side seat belt in my 2023 Toyota RAV4. After normal use, a child who had been properly secured in a child booster seat in the rear passenger-side seating position was unable to be released from the seat belt. The vehicle had not been involved in an accident, collision, or any emergency situation. The child had simply been riding in the vehicle under normal driving conditions. When it was time for the child to exit the vehicle, the rear passenger-side seat belt had become tangled and tightened around the child. The seat belt would not unlock or release despite repeated attempts to unbuckle it and allow the belt to retract or loosen. The restraint effectively trapped the child in the booster seat. Because the child could not be freed using the seat belt release mechanism, the only way to remove the child safely was to cut the seat belt. This occurred solely because the seat belt could not be released after ordinary use, not because of a crash or any other unusual event. A seat belt is intended to protect occupants while also allowing them to exit the vehicle safely after normal operation. In this case, the rear passenger-side seat belt failed to function as intended and created a serious safety hazard by trapping a child and requiring the seat belt to be cut in order to free them. I am requesting that this incident be investigated to determine whether the rear passenger-side seat belt or its locking mechanism has a manufacturing defect or design issue that could pose a risk to other occupants, particularly children using booster seats. I am able to provide additional information, photographs, repair records, or any other documentation requested as part of an investigation.

Source: NHTSA complaint ODI #11751540 · view all complaints for this vehicle at nhtsa.gov

Description of the Defect:I am reporting a premature and dangerous failure of the electronic door lock actuators on my 2023 Toyota RAV4 Hybrid SE. The issue began with the driver’s door lock intermittently failing to respond to the key fob and the internal master switch. Shortly after, the rear passenger door developed the exact same failure. Both doors can now only be operated strictly by manual intervention. The vehicle currently has over 36,000 miles, meaning this safety-critical component failed immediately after the expiration of the manufacturer's bumper-to-bumper warranty.Safety Risk:This component defect poses a severe safety hazard. In the event of a severe crash, electrical failure, or fire, passengers (especially children or occupants in the rear seats) face a high risk of entrapment, as the doors cannot be unlocked electronically for a quick evacuation. Furthermore, because the doors fail to lock automatically while driving, the occupants are left vulnerable to carjacking or external intrusion at intersections, and the doors could potentially be forced open by a child pulling the lever while the vehicle is in motion. This is a well-documented systemic issue across Toyota's 5th generation RAV4 platform, and a safety recall is urgently needed

Source: NHTSA complaint ODI #11757071 · view all complaints for this vehicle at nhtsa.gov