Toyota addresses a front transfer case issue (groan/buzzing noise) on certain 2019–2020 RAV4 AWD vehicles (specifically Adventure and Limited grades) through a Voluntary Emissions Recall / Customer Support Program (No. 20TE03) o

Source: NHTSA complaint ODI #11750703 · view all complaints for this vehicle at nhtsa.gov

The internal GPS compass is faulty, causing turn-by-turn instructions to be confusing, constantly changing, and suggesting illegal turns. These problems are constant, which makes driving dangerous unless GPS is not used. Evidence: [XXX] [XXX] Toyota acknowledges the problem, but will not fix it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Source: NHTSA complaint ODI #11758696 · view all complaints for this vehicle at nhtsa.gov

The contact owns a 2024 Toyota Rav4. The contact stated that while driving approximately 2–4 MPH, the vehicle independently accelerated. The brake pedal was depressed; however, the vehicle failed to stop as intended. The vehicle was uncontrollable. The vehicle drove onto a sidewalk curb and crashed into a concrete post before coming to a stop. There was no damage to the concrete post. The contact stated that the front camera and traction malfunction error messages were displayed. The contact stated that the failure had occurred while the contact was driving in a parking lot and attempting to park the vehicle. The vehicle was towed to a local collision shop. No Police report was filed. The contact sustained injuries to the upper chest from the impact and the seat belt. The contact had an upcoming appointment with the primary care physician. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 51,020.

Source: NHTSA complaint ODI #11758203 · view all complaints for this vehicle at nhtsa.gov

I own a 2024 Toyota RAV4. At approximately 38,300 miles, an authorized Toyota dealership diagnosed a failed rack-and-pinion/steering rack assembly that required replacement. Before the repair, I began noticing a squeaking noise when turning the steering wheel. The noise became progressively louder over time. The symptoms continued to worsen until the vehicle was inspected by the Toyota dealership. The vehicle has been regularly maintained, and there was no collision or other known event that would explain this failure. The steering rack required replacement only about 2,200 miles beyond Toyota’s 36,000-mile basic warranty. Because the rack-and-pinion assembly is a critical steering component, I am concerned that this may represent a premature failure and potentially a safety issue if similar failures are occurring in other 2024 Toyota RAV4 vehicles. I am submitting this complaint so the issue is documented and can be compared with reports from other owners. I have dealership repair documentation confirming the diagnosis and replacement of the steering rack assembly.

Source: NHTSA complaint ODI #11760067 · view all complaints for this vehicle at nhtsa.gov

Airbags, seats, and headrest all failed. State Farm insurance currently has the vehicle. I do not know if the people has been inspected by anybody. The vehicle had no warning lamps message or other symptoms of problems or failure before the collision. I was traveling in the far left lane when traffic came to abrupt stop and I was able to stop 10 to 15 ft from the vehicle in front of me. Two vehicles in my line behind me swerved out of the way. Then a semi truck with a trailer rear-ended me. The front end of the semi truck struck the rear end of my vehicle getting lodged inside my vehicle. My car was then pushed into the car in front of me and dragged 100 to 200 yards down The highway by the semi. The seat belts did not lock. The airbags did not deploy. Both front seat frames were bent and ripped apart. The rear seat that's became detached. The headrest for the front seats flew off. All four seats were occupied by adult males all weighing around 190 pounds or above. All four occupants were wearing seat belts. I the driver was knocked unconscious and received a concussion plus facial damage/injuries. Rear passenger side occupant received a broken jaw and a skull fracture. The other two passengers were also injured. All four passengers of the vehicle were transport to emergency room via ambulance.

Source: NHTSA complaint ODI #11756167 · view all complaints for this vehicle at nhtsa.gov

On 9/06/2026 my 2024 Toyota RAV4 Hybrid was involved in a severe collision where the impact occured on the drivers side at the passenger door. The vehicle spun several times before coming to a stop. During the spins the front passenger door flew opening. My wife was sitting in the passenger seat her seatbelt successfully restrianted her preventing ejection and injury. However the unlatching of a non impacted door under rotational forces represents a catastrophic structural or mechanical latch failure that poses an imminent risk occupant ejection.

Source: NHTSA complaint ODI #11762632 · view all complaints for this vehicle at nhtsa.gov

forward recognition camera malfunctioned which turns off all front camera associated systems including the entire toyota safety sense system. Precollison system malfunctions, lane tracing, adaptive cruise, and headlight system all malfunction when this camera is out. The car is only 2 years old and had to have the entire camera replaced for $2,000.

Source: NHTSA complaint ODI #11764251 · view all complaints for this vehicle at nhtsa.gov