rear axle locks up and transmission goes into limp mode , this happens when slow speed under acceleration, this happens almost any time in traffic , at stop light , acceleration to freeway. a safety issue, shows a p0700 code and p2729 code , engine service code light goes on , T/C and skid lights. also happen at hard brakes in traffic lights or fast slow downs

Source: NHTSA complaint ODI #11764253 · view all complaints for this vehicle at nhtsa.gov

Body to frame ground cables corroded in half two different times within about 6 months. First time engine wouldn’t start had to have it towed to dealer for repair, over 30 codes were shown when this happened. Next incident some of my lights were working intermittently and my steering was rendered inoperable for 20 to 30 seconds at a time making it impossible to steer the vehicle, several codes were found when this happened, I drove the truck to a Chevrolet dealer for repair. Both repairs were deemed to be corroded ground cables. Chevrolet has a “customer appreciation program” covering 2019-2024 Silverado trucks but for some reason my VIN number doesn’t land in the program even though it has the same issues that are covered for the other silverados.

Source: NHTSA complaint ODI #11762918 · view all complaints for this vehicle at nhtsa.gov

While driving my 2020 Chevrolet Silverado 1500, the braking system suddenly malfunctioned without any prior warning. When I released the accelerator, the vehicle began slowing as though the brakes were being applied even though I was not pressing the brake pedal. When I attempted to brake normally, the vehicle did not stop as expected and braking ability was significantly reduced. The red BRAKE warning, ABS warning, traction/ESC warnings, and check engine light illuminated. The dashboard displayed “Brake System Failure – 43 MPH Top Speed,” “Service ESC,” and “Service Trailer Brake System.” Because of the reduced braking ability, I stopped the vehicle and had it transported by flatbed tow to a Chevrolet dealership rather than continue driving it. The Chevrolet dealer inspected the vehicle and documented diagnostic trouble codes P25A2 and C053D. The dealer stated that the Brake System Control Module requested the warning light and that updated software was available to address these codes. The dealer reprogrammed the Brake System Control Module according to a GM technical service bulletin. No mechanical brake components were replaced. I was charged $362.95 for the diagnosis/reprogramming. I am reporting this because the failure occurred suddenly while the vehicle was being driven and resulted in significantly reduced braking ability, creating a serious risk of a crash. The vehicle had approximately 74,221 miles at the time of the incident. The dealer repair invoice documenting the codes and repair is available upon request.

Source: NHTSA complaint ODI #11762914 · view all complaints for this vehicle at nhtsa.gov

While driving I lost the power steering on the vehicle. I took my truck to a chevy dealership and scheduled an appointment for the following day. I research the problem and found that there was a Customer Satisfaction Program bulletin (N252515590) issued covering this specific issue for my trucks model year but it did not cover my specific VIN. I contacted Chevrolet Customer Assistance and they told me to file a complaint with NHTSA.

Source: NHTSA complaint ODI #11764335 · view all complaints for this vehicle at nhtsa.gov

The contact owned a 2020 Chevrolet Silverado 1500. The contact stated that while stopped at a stop light, he observed smoke emanating from the area of the vehicle between the cab and the bed, prompting him and the other occupants to quickly evacuate. Within moments, the vehicle caught fire and was engulfed in flames. Local emergency services arrived and were able to extinguish the fire. The contact was informed that fire investigators on scene determined that the fire had appeared to originate in the electrical system associated with the seat belt located behind the rear passenger side seat. No warning lights were illuminated. The vehicle was towed to a tow yard and was likely to be deemed a total loss by the contact's insurance provider. A fire report was filed. A police report was filed, and no injuries were reported. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 19V814000 (Seat Belts); the VIN was included, but the vehicle had already been repaired. The manufacturer was not notified of the failure. The failure mileage was 100,000.

Source: NHTSA complaint ODI #11665057 · view all complaints for this vehicle at nhtsa.gov

What component or system failed or malfunctioned, and is it available for inspection upon request? The A/C condenser and the vehicle battery failed. The failed components are available for inspection upon request. How was your safety or the safety of others put at risk? The A/C failure causes the driver's side to blow warm air, creating severe window fogging and reducing visibility in extreme weather, while the electrical/battery failure compromises vehicle operation and safety features. Has the problem been reproduced or confirmed by a dealer or independent service center? The A/C issue matches General Motors Technical Service Bulletin PIT5767A, caused by an internally bypassing condenser due to a mispositioned block-off plate. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle has not yet been officially inspected by a manufacturer representative, but the defect aligns with known GM manufacturing specifications under bulletin PIT5767A. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Symptoms appeared suddenly with the air conditioning losing performance (driver's side blowing significantly warmer than the passenger side) alongside concurrent battery and electrical system failures.

Source: NHTSA complaint ODI #11764002 · view all complaints for this vehicle at nhtsa.gov