I am filing this safety complaint regarding excessive oil consumption in my 2020 Hyundai Palisade, which presents a direct vehicle stalling and engine failure hazard while driving at highway speeds. My vehicle is currently consuming approximately 5 quarts of engine oil every 3,000 miles. This severe oil loss occurs rapidly between scheduled maintenance intervals without any illuminated dashboard warning lights, low oil pressure indicators, or visible oil leaks on the ground. The oil is burning internally within the combustion chamber. This creates an extreme safety risk. If the oil level drops dangerously low before the next service, the engine is at risk of sudden catastrophic failure, severe overheating, or immediate stalling while in motion. A sudden loss of propulsion while driving in heavy traffic or at highway speeds places myself, my passengers, and other drivers at risk of a serious collision. Furthermore, the lack of an early warning sensor or dashboard indicator for low oil volume means the driver is left entirely unaware of the hazard until the engine begins to fail. Hyundai is well aware of this widespread oil-burning defect in their V6 engines, yet because my vehicle has reached 160,000 miles, they refuse to provide any diagnostic support, remedy, or warranty assistance. I am requesting that the NHTSA open a formal investigation into the 2020 Hyundai Palisade engine oil consumption defect to compel the manufacturer to issue a safety recall before a catastrophic stalling event causes a fatal accident.

Source: NHTSA complaint ODI #11764275 · view all complaints for this vehicle at nhtsa.gov

This vehicle has suffered two identical, catastrophic electrical failures causing an immediate and total loss of engine power while traveling at highway speeds. The first incident occurred after the engine was replaced under a Hyundai extended warranty. The dealership service department blamed that failure on a loose engine ground strap and released the vehicle back to me. On August 3, 2026, the exact same failure occurred for a second time while driving at high speed on the highway. The vehicle lost all propulsion, leaving me exposed to oncoming traffic with zero engine power. The vehicle was towed to a Hyundai dealership. The dealership identified a blown "Sensor 4" fuse causing an intermittent dead circuit, but they have been unable to locate the short circuit after two weeks of troubleshooting. After demanding the diagnostic data logs, the dealership abruptly halted all repairs and ordered me to pick up the vehicle. Furthermore, due to excessive, repetitive diagnostic cranking and idling in 90+ degree heat while under the dealer's care, the vehicle's starter solenoid has now suffered collateral failure. The vehicle is currently completely disabled, undrivable, and the underlying highway stalling hazard remains completely unresolved. This is a recurring, severe life-safety issue that leaves the vehicle prone to sudden stall events in high-speed traffic without warning.

Source: NHTSA complaint ODI #11757633 · view all complaints for this vehicle at nhtsa.gov

I have a 2020 palisade limited with the self leveling shocks. I have about 78,000 miles on the car. I am on my second set of replacement of the rear shocks. Well, guess what? I’m starting to hear that clunking noise again. I love my palisade but quickly becoming tired of this issue. I relaced the shocks last summer (Aug 2025). So, just less than one year after the replacement the noise is back and the smoothness of driving is gone. Every hole feels extremely rough.

Source: NHTSA complaint ODI #11742108 · view all complaints for this vehicle at nhtsa.gov

My 2020 Hyundai Palisade is affected by NHTSA Safety Recall 25V607 / Hyundai Recall 283 involving the first- and second-row seat belt buckle assemblies. The recall was initiated in 2025, and my vehicle remains unrepaired approximately one year later. This defect has actually occurred in my vehicle. Seat belts have released/unlatched while the vehicle was being driven, creating a serious risk that an occupant could become unrestrained while the vehicle is moving or in the event of a collision. The Hyundai dealership documented Recall 283 as outstanding on my vehicle in March 2026. I returned to the dealership in September 2026, and the recall remained unrepaired because the required parts were unavailable. Hyundai Motor America has since confirmed in writing that the required parts are back-ordered. Hyundai states that a set has been assigned to my vehicle, but there is currently no estimated time of arrival. Approximately one year after this safety recall was initiated, my affected vehicle remains unrepaired despite the seat belt defect having actually occurred while driving. I am concerned about safely transporting my family while waiting indefinitely for the required repair.

Source: NHTSA complaint ODI #11764865 · view all complaints for this vehicle at nhtsa.gov

The paint on the roof of my 2020 Hyundai Palisade is peeling off in large sheets, rather than typical chipping or wear. The peeling originates from the center of the roof and has begun spreading toward the area near the front windshield edge. This is not consistent with normal wear and tear, curb rash, or impact damage — the affected areas show clean separation of paint layers down to a lower coat/primer, consistent with a manufacturing defect in paint adhesion or application. Rust is beginning to be visible. Based on research, this appears to be a widespread issue among other 2020 Hyundai Palisade owners, many of whom report similar peeling on roofs, hoods, and wheels, suggesting a systemic paint defect rather than an isolated incident. Date first noticed July 2026 Current mileage 32,006

Source: NHTSA complaint ODI #11759537 · view all complaints for this vehicle at nhtsa.gov

I am reporting a serious safety defect involving the A/C system on my 2020 Hyundai Palisade. The A/C system has failed due to a manufacturer acknowledged defect in the compressor pulley and hub assembly. Hyundai has issued multiple Technical Service Bulletins (TSB 21‑HA‑003H, 24‑HA‑003H, 25‑HA‑003H / 003H‑1) documenting this exact failure pattern. These TSBs confirm Hyundai is aware of widespread A/C failures in this model. Despite acknowledging the defect in writing, Hyundai has refused to repair the vehicle, citing “time in service and mileage,” even though the failure is directly tied to a known defective component. This refusal leaves a safety‑critical defect unaddressed. This is not a comfort issue. This vehicle is used for medical transportation of a medically needy child who requires strict temperature regulation. Loss of A/C in Florida heat creates a dangerous and medically hazardous environment inside the vehicle. The cabin temperature rises rapidly, creating a risk of heat‑related medical complications. This is a clear safety hazard, not a cosmetic or convenience problem. The A/C failure is sudden, unpredictable, and cannot be mitigated by the driver. The defect results in: Complete loss of cooling in high‑heat conditions Inability to maintain medically safe cabin temperatures Documented component failure acknowledged by Hyundai Manufacturer refusal to correct a known defect Increased risk of medical harm to a vulnerable passenger Hyundai’s denial of assistance despite multiple TSBs proving the defect demonstrates a failure to address a safety related mechanical issue that directly impacts occupant health. This defect should be investigated as a potential widespread safety problem affecting 2020 Hyundai Palisade vehicles. I am requesting NHTSA’s review and investigation into this defect due to the significant safety risk, the manufacturer’s documented knowledge, and the potential for medical harm caused by the failure of the A/C system.

Source: NHTSA complaint ODI #11763168 · view all complaints for this vehicle at nhtsa.gov