Ask the seller for proof the repair was completed, or run the free VIN check. Recall repairs are done at no cost by a dealer.
Recalls
Safety issues the manufacturer must repair for free. A recall means confirm the fix was done, not walk away.
Structure recall
Third-row seats with inadequate strength may fail to protect occupants, increasing the risk of injury in a crash.
- Remedy
- Dealers will inspect and repair the frame, as necessary, free of charge. Owner notification letters were mailed December 17, 2025. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3RASCHW. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning October 31, 2025.
- Status
- Remedy available. Confirm by VIN that this repair was completed.
- What to do
- Enter the VIN on NHTSA's recall lookup to confirm this car was repaired.
Suspension recall
An axle that moves out of position can cause a loss of vehicle control, increasing the risk of a crash.
- Remedy
- Dealers will replace the spring U-bolts, free of charge. Owner notification letters were mailed August 23, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3FEDERB.
- Status
- Remedy available. Confirm by VIN that this repair was completed.
- What to do
- Enter the VIN on NHTSA's recall lookup to confirm this car was repaired.
Electrical system recall
An overheated ground connection can increase the risk of a fire, and a loss of drive power can increase the risk of a crash.
- Remedy
- Dealers will inspect and repair the 12-Volt ground connection, as necessary free of charge. Owner notification letters were mailed May 3, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3HVERSL.
- Status
- Remedy available. Confirm by VIN that this repair was completed.
- What to do
- Enter the VIN on NHTSA's recall lookup to confirm this car was repaired.
Electrical system recall
A short circuit increases the risk of a fire. In addition, a loss of drive power, power steering, and brake system control increases the risk of a crash.
- Remedy
- Dealers will inspect the routing of the main wiring harness and correct it, as necessary, free of charge. Owner notification letters were mailed April 5, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BEFHAU.
- Status
- Remedy available. Confirm by VIN that this repair was completed.
- What to do
- Enter the VIN on NHTSA's recall lookup to confirm this car was repaired.
Structure recall
A detached partition wall can increase the risk of injury.
- Remedy
- Dealers will inspect and secure the partition wall as necessary, free of charge. Owner notification letters are expected to be mailed February 16, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3TREWAN.
- Status
- Remedy available. Confirm by VIN that this repair was completed.
- What to do
- Enter the VIN on NHTSA's recall lookup to confirm this car was repaired.
Suspension recall
A loss of steering control can increase the risk of a crash.
- Remedy
- Dealers will inspect the front left suspension strut bolt connection and repair the body contact surface as necessary, free of charge. Owner notification letters were mailed January 31, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3FEDDOR.
- Status
- Remedy available. Confirm by VIN that this repair was completed.
- What to do
- Enter the VIN on NHTSA's recall lookup to confirm this car was repaired.
Structure recall
An insufficiently bonded window can detach during a crash, and objects secured to an insufficiently bonded interior lashing rail can detach, increasing the risk of injury.
- Remedy
- Dealers will inspect the paint adhesion and repair it as necessary, free of charge. Depending on the extent of any damage, DVUSA may offer to repurchase the vehicle. Interim notification letters, notifying owners of the safety risk, were mailed February 5, 2024. Owner notification letters were mailed November 4, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3LACKHA.
- Status
- Remedy available. Confirm by VIN that this repair was completed.
- What to do
- Enter the VIN on NHTSA's recall lookup to confirm this car was repaired.
Owner complaints by system
Unverified reports owners filed with NHTSA, grouped by the part of the car. Useful for spotting patterns. Open a group to read recent examples.
Engine & powertrain
8
Most reports here involve sudden stalling.
Read full complaint
On January 19, 2026, my neighbors / daughter noticed smoke was coming from under the van that had been parked for over 3 hours. Shortly after, he confirmed the van had caught fire. I asked him to call the fire department.
Source: NHTSA complaint ODI #11748198 · view all complaints for this vehicle at nhtsa.gov
Brakes
1
Most reports here involve software faults.
Read full complaint
The contact owns a 2023 Mercedes-Benz Sprinter 2500. The contact stated that while driving approximately 55-65 MPH, the Crosswind Assist inadvertently activated, causing the front and rear driver's side brakes to activate. The vehicle started swerving. The Crosswind Assist warning light was illuminated. The failure occurred on four separate occasions. The vehicle was taken to the dealer; however, no error codes were retrieved. The dealer determined that the vehicle had recalibrated while driving. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 2,100.
Source: NHTSA complaint ODI #11556272 · view all complaints for this vehicle at nhtsa.gov
Steering, suspension & tires
2
Most reports here involve loss of steering.
Read full complaint
My issue is only the crosswind assist. We purchased this van new, it has 3000miles of use not driving to the dealership and back. We cannot drive this van on the freeway and due to this "safety" feature nobody but myself will get behind the wheel fearful of crashing when this turns on at 100% random times. Infact it went off 23times in an 18mile stretch the last time I drove it. I've contacted the customer service line 4 times. Nobody there has been any help and twice I've been hung up on. I've had it to the dealership 4 times for a total of 5 weeks. Finally the last time I refused to leave unless the test drove it. Which they did and lo and behold the tech walked in absolutely pissed because he just about got rear ended by a semi due to the crosswind assist. So, your own employees have experienced this and cannot fix it. I'm beyond irritated. 65,000$ service van I have paid on for a year, ins, custom racks, shelving, decals. Mercedes sold me on reliability and service. I own a van that will eventually hurt somebody. I am currently drafting legal docs to move this forward with the help of your own employees testimony. I'm done wasting my time Your vans are a death trap
Source: NHTSA complaint ODI #11591184 · view all complaints for this vehicle at nhtsa.gov
Structure & body
1
Most reports here involve other issues.
Read full complaint
So I bought a brand new 2023 Mercedes Sprinter Build by Airstream Interstate 19. The front windshield visibility is very bad at night driving. The whole front of windshield has zig zag lines all over the glass for defrosting but those lines make on coming traffic lights very blurry. Driving during day time is normal. Driving during night time all lights look blurry, its kind of like driving with -2 or -3 prescription when looking out the windshield. I called airstream and they said windshield is part of mercedes item. I called mercedes knoxville and they said they have not heard anything like this before.
Source: NHTSA complaint ODI #11511974 · view all complaints for this vehicle at nhtsa.gov
Other systems
5
Most reports here involve other issues.
Read full complaint
2023 Sprinter van jack was pulled out for the first time to be used last week and found to be unsafe. The jack base is crowned in center, the edges flare upwards and large gouge/groove in metal base, causing the jack to noticeably wobble and rock in manner that it is unsafe to use, fear of jack tilting and dropping van onto user of jack. Jack base has obvious defects and unsafe to use. Have contacted dealer and referred to MBUSA who provided a case # and no resolution to provide a safe jack to replace the defective jack.
Source: NHTSA complaint ODI #11700815 · view all complaints for this vehicle at nhtsa.gov
How does it compare with other years? The 2023 has 17 complaints on file, fewer than the 2022 (40) and more than the 2024 (12). Of the 13 model years of the Mercedes-Benz Sprinter 2500 we cover, the 2020 has the most (80). Older model years have had longer to collect complaints.