Driving as normal through a major intersection and the car began to jerk and stutter when trying to accelerate. there was no warning or symptom prior to this issue, but upon it happening, the turtle warning light appeared and had the display had an engine system message saying "reduced performance". I was able to pull over. Then turned the car off and back on, which then allowed me to pull in to the nearest parking lot. The warning light remained on. The car was towed to the nearest Volvo dealership. They confirmed the issue was a failure of the fuel pump. They replaced the fuel pump. Luckily I had passed the intersection and the cars around me were still accelerating from a lower speed, so this did not cause an accident.

Source: NHTSA complaint ODI #11630286 · view all complaints for this vehicle at nhtsa.gov

The contact owns a 2021 Volvo XC60. The contact stated while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact pulled over to the shoulder, and the vehicle continuously turned on and off independently. The check engine warning light was illuminated. The vehicle was towed to the dealer, who determined that the auxiliary battery power was low and that the vehicle needed a software update. The vehicle was repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 18,000.

Source: NHTSA complaint ODI #11626461 · view all complaints for this vehicle at nhtsa.gov

Around 10/26/2024 I purchased a 2021 Volvo XC60 from Carvana. Carvana sells vehicles with a 100 day limited warranty. The manufacturer warranty was expired at this time. Carvana states they do an inspection of the vehicle prior to delivery. When I received the vehicle, I noticed the steering wheel would vibrate hard when I came to a stop. I took the Volvo to the local Volvo dealership to perform a full multi-point inspection. They found that the brake pads were at 1-2 MM with warped rotors on the front wheels. The back wheels had 3 MM brake pads. I called Carvana on 11/22/2024 to discuss the brake issue and inquired about the 100 day warranty to cover the brake repair because I was sold a very unsafe vehicle. I was told their warranty would not cover the cost to repair the brakes. I asked for the inspection report they did prior to delivering the Volvo. They will not release the inspection report to me. So I asked for the details of the inspection on the brakes. They told me their inspection showed front wheels with 6m on both and the rotors were at 29 (LF) and 28.02 (RF). They told me the rear wheels had 6M on brake pads for both wheels and the rotors were 11 (LR) ad 11.92 (RR). They could not tell me the date of the inspection. I trust the Volvo Dealership to provide accurate information on their inspection. This is not a safe vehicle and should have the brakes replaced AND Carvana should pay for this cost. At this point, Carvana is selling very dangerous and unsafe vehicles and declining to provide inspection reports. I ask for your help with contacting Carvana and absolutely requiring them to repair and replace the brakes on the vehicle they sold me.

Source: NHTSA complaint ODI #11626930 · view all complaints for this vehicle at nhtsa.gov

The contact owns a 2021 Volvo XC60. The contact stated that while driving at undisclosed speeds and turning, the front end of the vehicle made an abnormal grinding sound. Additionally, the contact stated that the steering wheel seized after turning, which required the contact to jam the steering wheel for the steering wheel to return to the center. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the steering rack had failed internally and needed to be replaced. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 23V001000 (Steering); however, the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was approximately 45,000.

Source: NHTSA complaint ODI #11688891 · view all complaints for this vehicle at nhtsa.gov

The passenger side rear door locked and could not be open from either the inside or the outside. The dealer concluded that the door lock failed in the locked position. It gained entry to the door panel with the door shut, removed the old lock, opened the door, installed a new lock assembly and reassembled the door. Because the car was slightly out of warranty, we had to pay for the repair. Until this was done, we felt very unsafe. In the event of an accident or emergency, the passenger on that side of the car would not be able to exit the car. There was no warning prior to this happening. It just stopped working.

Source: NHTSA complaint ODI #11631036 · view all complaints for this vehicle at nhtsa.gov

The BLIS warning light has been malfunctioning and only displaying intermittently for several weeks. We were traveling from Florida to Massachusetts when we discovered the problem. We made arrangements for the car to be serviced twice, but they informed us they did not observe the issue during their test drive the first time. The second time they indicated that although the signal only activates intermittently, it is designed to function intermittently. We were informed that it will only activate if our car is going the same speed as the car we are passing or the car that is passing us. They subsequently advised the indicator will not activate if there is a 9 mph difference between the passing vehicle and the car being passed. We previously understood the indicator would be a signal or warning that it is not safe to return to the lane of the cars we are passing or move to the lane of the cars that are passing us. I have videos detailing what we perceive as the problem.

Source: NHTSA complaint ODI #11484780 · view all complaints for this vehicle at nhtsa.gov